2017 Chevrolet Volt power train problems

“I am reporting a suspected Battery Energy Control Module (BECM) failure in my 2017 Chevrolet Volt. My vehicle has experienced multiple symptoms consistent with the known BECM defect documented by General Motors, including intermittent failure to start, reduced propulsion power, and failure to operate on electric power despite the high-voltage battery being fully charged. When the vehicle did start, it would run using the gasoline engine instead of the fully charged battery. The vehicle also experienced reduced propulsion power, limiting acceleration and creating a serious safety concern, particularly when merging into traffic, crossing intersections, or driving at highway speeds. The intermittent starting failures also create a risk of becoming stranded. My vehicle has generated multiple diagnostic trouble codes associated with these malfunctions, which are available for review. These symptoms are consistent with those identified in GM Technical Service Bulletin 18-NA-261 and Special Coverage Program N232432680. GM established extended BECM warranty coverage of 15 years or 150,000 miles for eligible 2016–2018 Chevrolet Volts. However, despite my vehicle being a…”

“My 2017 Chevrolet Volt, with 97,758 miles, experienced a failure that rendered the vehicle inoperable. The vehicle would not start or operate normally. The vehicle was taken to an authorized Chevrolet dealership for diagnosis. After several days, the dealership confirmed that the Battery Energy Control Module (BECM) had failed. The dealership quoted approximately $2,500 for replacement, including parts and labor. This failure presents a serious potential safety concern because BECM malfunctions can result in loss of propulsion, reduced power, or an inability to restart the vehicle, potentially leaving drivers stranded in unsafe locations. General Motors has previously recognized BECM failures in certain Chevrolet Volt vehicles and established a special coverage adjustment for affected vehicles. However, despite my vehicle experiencing the same diagnosed component failure, GM informed me that my VIN was excluded from the coverage program. I contacted General Motors directly and opened a case. GM confirmed that my repair would be considered an out-of-pocket expense and advised me to report the failure to NHTSA. I believe this failure warrants investigation…”

“Received "reduced propulsion" message, with no engine detected. Car slowed to a near stop while driving on the Interstate highway. Very dangerous to have that suddenly happen. Message popped up randomly with no prior warning.”

“Failure of Battery Energy Control Module (BECM), within the high voltage battery. Vehicle is unable to charge and sets “reduced power” message. GM released special coverage bulletin for this issue (N232432680), but this vehicle is not listed due to which state it was registered. Continued failure of the BECM will lead to inoperability of the vehicle.”

“Three separate high-voltage battery section failures within one year, each causing complete loss of propulsion. Two occurred at freeway speeds on [XXX]. FAILURE 1 ([XXX]): Vehicle lost propulsion. Dealer diagnosed DTC P0AFA (low voltage), failed cell in Battery Section 3. Section 3 replaced under GM Special Coverage N232432680 (BECM, 15yr/150k). Vehicle out of service approximately six months awaiting GM authorization and parts. FAILURE 2 ([XXX]): Vehicle lost propulsion on [XXX] at night at freeway speeds. Required towing. Dealer diagnosed DTC P0AFA, Cell 85 at 1.85V in Battery Section 1 (different section). Section 1 replaced under same Special Coverage. Vehicle returned Jan 28, 2026. FAILURE 3 ([XXX], ~300 miles after Failure 2 repair): Vehicle again lost propulsion on the freeway with check engine light, then progressed to no-start condition. Towed to dealer. Diagnosed Feb 20, 2026: DTC P0AFA, Cell 57 at 1.5V in Battery Section 2 (GM minimum spec 2.5V). Third distinct section failure. Vehicle remains at dealer awaiting GM repair authorization as of filing date. SAFETY CONCERN: Loss of propulsion at freeway speeds is an immediate safety hazard. During the…”

“I am reporting a series of safety concerns regarding my 2017 Chevy Volt, which have persisted despite multiple attempts to address them with the dealership. These issues pose significant risks to my safety and that of others on the road. On January 18th, 2024, I brought my vehicle to the dealer after experiencing reduced propulsion power while driving on the highway, coupled with the illumination of the check engine light. The mechanic performed a quick inspection and used a GM scan tool to diagnose the issue, revealing the code P1E00 for the Hybrid Powertrain Control Module 2, which was cleared without a thorough investigation. I was advised to return if the issue reoccurred. Despite the reset, the problem persisted, and on February 9th, 2024, I scheduled another appointment due to my Chevy Volt's High Voltage battery charging only to 65% capacity despite indicating a full charge. Subsequently, on February 11th, 2024, the check engine light illuminated again, and on February 12th, 2024, November 25th, 2025, January 11th, 2026, and February 12, 2026 while driving to work, both times I experienced a loss of propulsion power on the highway, placing my safety at…”