2001 Chrysler PT Cruiser service brakes, hydraulic problems

“WEB SITE TOPIX WILL CONFIRM THE INCREDIBLE # OF FOLKS THAT HAVE HAD FOG LAMPS TURN ON AFTER CAR IS SHUT DOWN CAUSING BATTERY DRAIN. 100'S HAVE PAID FOR REPLACEMENT PART MULTI-FUNCTION SWITCH. THIS CONTROLS FOG, HEAD, ACCESSORY, & DASH LIGHTING. TO PREVENT THE FOG LAMPS FROM COMING ON BY THEMSELVES, MOST HAVE REMOVED FUSE # 8 TO REMOVE THE FOG LAMPS FROM THE CIRCUIT. PEOPLE REPORT SMOKE COMING FROM TURN SIGNAL LEVER, & THE COMPLETE LOSS OF ALL LIGHTING IS QUITE COMMON. I PERSONALLY HAVE REPLACED THE MULTI-FUNCTION SWITCH 3 TIMES ON MY WIFE'S 2001 P.T. CRUISER WITH ONLY 50,000 TOTAL MILES & SHE BEING ORIGINAL OWNER. BY PARKING HER CAR MINUS FUSE # 8, NOT USING DOME LIGHTING, & ALWAYS PARKING WITH THE SIGNAL LEVER IN THE DOWN OR LEFT TURN POSITION HAS PREVENTED THE MYSTERY FOG LAMP ISSUE, & KEPT HER BATTERY FUNCTIONING. THIS "TEMP" SOLUTION HAS ALLOWED HER ABOUT 6 OR 8 MONTHS OF DRIVING W/O THE PROBLEMS OTHER PT OWNERS STRUGGLE WITH. SOONER OR LATER SOMEONE WILL LOSE LIGHTING OR A FIRE WILL OCCUR INSIDE THE STEERING WHEEL WHICH WILL CAUSE SERIOUS INJURY, LOSS OF VEHICLE & POSSIBLY DEATH. CHRYSLER DENIES ANY KNOWLEDGE, BUT WANTS MORE THAN $1,000.000 TO ANALYZE &…”

“TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT STATED THAT SHE REPLACED HER ENTIRE BRAKE SYSTEM IN AUGUST 2008; HOWEVER, THE FAILURE HAS RECURRED. A SECOND CHRYSLER DEALER ALSO ADVISED HER THAT SHE HAD TO REPLACE THE ENTIRE BRAKE SYSTEM. THE CHRYSLER MANUFACTURER INFORMED THE CONTACT TO TAKE HER VEHICLE TO A DEALER TO HAVE IT REPAIRED. THERE WERE NO RECALLS AND THE WARRANTY HAS EXPIRED. THE FAILURE MILEAGE WAS 34,837 AND THE CURRENT MILEAGE WAS 47,420.”

“TL*THE CONTACT OWNS A 2001 CHRYSLER PT CRUISER. THE CONTACT PURCHASED THE VEHICLE IN NOVEMBER OF 2007 AND THE WIRING HARNESS WAS REPLACED DUE TO ELECTRICAL FAILURES. IN APRIL OF 2008, WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE ACCELERATED ON ITS OWN. THE VEHICLE WAS TOWED TO THE DEALER AND THEY REPLACED THE BRAKE PADS AND CALIPERS. RECENTLY, THE ENGINE LIGHT ILLUMINATED ON THE INSTRUMENT PANEL. THE DEALER'S DIAGNOSTIC INDICATED THAT THE TRANSMISSION SOLENOID SWITCH NEEDED TO BE REPLACED, ALONG WITH THE POWER STEERING PUMP. THE DEALER STATED THAT THE WARRANTY DOES NOT COVER THE PARTS. THE MANUFACTURER STATED THAT THERE WERE NO RECALLS THAT APPLIED TO HER VIN. THE FAILURE MILEAGE WAS 68,000 AND CURRENT MILEAGE WAS 75,551.”

“) ON 9/2/03 I HAD TO TAKE THE CAR IN TO HAVE THE BRAKES CHECKED. PROBLEM FOUND WAS THE FRONT RIGHT CALIPER PISTON STUCK > CLOSED CAUSING UNEVEN WEAR > OF BRAKES PADS ( METAL TO METAL ON FRONT RIGHT AND 50% PADS ON OTHER THREE). DEALER REPLACED THE CALIPER PISTON, REPLACED PADS AND MACHINED ROTORS. HAD TO GET A RENTAL FOR ONE DAY. 2) ON 2/21/05 HAD THE CAR IN THE SHOP AGAIN TO HAVE THE TIRES ROTATED AND BRAKES CHECKED. DEALER SAID ALTHOUGH THE PADS WHERE WEARING EVENLY NOW, THEY STATED "BUT WORN OUT FRONT AND REAR", NEED TO BE REPLACED. BRAKES FRONT AND REAR, REPLACED FRONT ROTORS, RESURFACED REAR ROTORS" THIS TIME I HAD TO HAVE A RENTAL FOR THREE DAYS. 3) ON 3/12/05 NOT EVEN A MONTH LATER, WHILE I WAS DRIVING ON THE FREEWAY TO WORK THE, ENTIRE WINDSHIELD BECAME ENGULFED WITH STEAM, I COULD NOT SEE A THING AND THE WIPERS COULD NOT TAKE THE STEAM AWAY, SO AGAIN I HAD TO HEAD BACK TO THE DEALERSHIP TO HAVE THIS CHECKED OUT. DEALER STATED "FOUND ENGINE COOLING FAN NOT WORKING & RADIATOR CAP NOT HOLDING PRESSURE" " REPLACED FAN AND RADIATOR CAP". ANOTHER RENTAL FOR TWO DAYS. 4) ON 6/14/06, 161 MILES AFTER THE EXTENDED WARRANTY RUNS OUT, I HAVE A MAJOR TRANSMISSION…”

“DT: THE CONTACT STATES THERE IS A NHTSA RECALL CAMPAIGN 04V268000 CONCERNING THE STEERING HYDRAULIC POWER ASSIST HOSES, PIPING, AND CONNECTIONS. THIS VEHICLE EXPERIENCED THE SAME SYMPTOMS AS INDICATED IN THE RECALL, BUT THIS AFFECTED THE BRAKE FLUID LINES AS WELL. SHE REPAIRED THE VEHICLE AT HER OWN EXPENSE PRIOR TO RECEIVING THE RECALL LETTER. *AK”

“DT THE BRAKE LINES COLLASPED AND HAS NOT ALLOWED THE BRAKE FLUID TO GO THROUGH. HAS TO GRIP STEERING WHEEL AND PULL OVER IN ORDER TO GET THE VEHICLE TO STOP SHAKING. STANDING NEXT TO THE BRAKES CONSUMER CAN FEEL THE HEAT COMING OFF THE BRAKES. THIS HAPPENED IN MAR 2005. TUFFY FIXED IT, THEY SAID HAD OTHER PT CRUISER'S IN FOR THE SAME DEFECT. THE SECOND TIME THIS HAPPENED IT ALMOST CAUSED AN ACCIDENT WHEN HITTING THE BRAKES IT SHOOK BADLY. IT WAS UNCONTROLABLE AT THAT POINT. *AK”