2011 Dodge Grand Caravan engine problems

“The contact owns a 2011 Dodge Grand Caravan. The contact stated that while starting the vehicle, there was an abnormal whining sound coming from the engine. There was no warning light illuminated. The vehicle was taken to an independent mechanic where the water pump was replaced. The contact stated that several months later, while driving 65 MPH, the steering wheel seized without warning. The contact used excessive force to steer the vehicle to an independent mechanic, where a power steering flush was performed; however, the failure persisted. The mechanic replaced the steering pump, which seemed to correct the failure. The contact then stated that the whining sound returned without warning. The vehicle was taken back to an independent mechanic, where the contact was informed that the valves inside the engine connected to the fuel injector were defective and needed to be replaced. The contact stated that after the diagnostic tests, the vehicle failed to start up after several attempts. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to file a complaint. The vehicle was not repaired. The failure mileage was approximately 130,000.”

“The contact owns a 2011 Dodge Grand Caravan. The contact stated that the engine turned over, but the vehicle failed to start. The contact became aware that the jumper ends were burned. There was no fuel entering the engine. The contact stated that the silicon on the relays needed to be replaced and the fuel pump had failed. Additionally, the driver's side window became inoperable. There were no warning lights illuminated. The contact called the local dealer, but the vehicle was not diagnosed or repaired. The contact stated that the failure was related to NHTSA Campaign Number: 19V813000 (Electrical System). The manufacturer was contacted and referred the contact to the NHTSA Hotline. The failure mileage was approximately 160,000.”

“Dealership still cannot pinpoint exactly what is wrong but the car does not start. One time it’ll start and the next it won’t. It’s actually left me stranded in the cold because that seems to be the only time it won’t start. It’s happened to many other grand caravan owners too. No mechanic I’ve taken it to can solve the problem I’ve spent so much money replacing parts on this car.”

“Vehicle randomly dies completely like no battery connected either while parked or in motion. Then after a few moments vehicle starts like nothing is wrong. No codes no warning.”

“This vehicle always fails to start in the colder weather. After a review of this condition. It has been found that the fuel pump relay does not send proper signal. This relay is a part of the Totally Integrated Power Module (TIPM). When it fails to operate, the vehicle will experience long crank times. With its ignition switch style, as soon as you turn the key, the vehicle will continue to crank UNLESS you manually turn the switch all the way back to the off position. This condition will cause the starter motor to overheat or burn up. Eventually the vehicle may start then die. Fuel delivery is too inconsistent when colder weather arises. You can't just replace a plug-in-style replacement fuel pump relay since it is a part of the whole TIPM. This vehicle has not yet died in traffic or on the highway thank God. There is never any CEL illumination or any stored fault codes. It started doing this the first winter I bought it. This is my second year and it's only just Fall and it is acting up again. This is a KNOWN issue among these TIPMs that are on more than just this vehicle but many other Dodge/Chryslers with this same TIPM. Someone needs to take accountability…”

“The contact owns a 2011 Dodge Grand Caravan. The contact stated that while driving at 35 MPH, the vehicle stalled inadvertently. There were several unknown warning lights illuminated on the instrument panel. The contact was able to veer to the side of the road, where he successfully restarted the vehicle. The vehicle was taken to an independent mechanic where it was diagnosed that the fuel pump needed to be replaced. The contact stated that after the vehicle had been repaired, the vehicle would fail to start intermittently, and would only start after several attempts. An unknown dealer was notified of the failure and informed the contact that there were no open recalls on the vehicle. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 200,000. THE CONSUMER STATED THE VEHICLE WAS REPAIRED BY REPLACING THE INGNITION SWITCH. THE CONSUMER DISCOVERED AN IGNITION SWITCH RECALL THAT THE VEHICLE WAS NOT INCLUDED IN DUE TO THE MODEL YEAR. THE CONSUMER REQUESTED THAT THE VEHICLE BE INCLUDED IN THE RECALL, AS IT DISPLAYED THE SAME FAILURE DETAILED IN THE RECALL NOTICE.”