2021 Ford Bronco electrical system problems

“While driving, I experienced the brakes beginning to fail, followed shortly by a complete loss of engine power. My 2021 Ford Bronco is subject to recall 25S75 (NHTSA 25V455) for a low pressure fuel pump defect that can cause loss of fuel pressure or flow and engine stall. I was stranded on the side of the interstate in 100 degree heat with my newborn in the vehicle. This was a dangerous situation, not a minor inconvenience. I had the vehicle towed to an AAA Car Care Center in Charlotte, NC, where the fuel pump failure was diagnosed. AAA could not perform a repair because the issue falls under an open safety recall. I contacted the Ford Recall Assistance Center and was told no remedy is currently available for recall 25S75. I also visited Capital Ford Charlotte, who confirmed the same, that no remedy exists yet. With the vehicle inoperable and no repair available anywhere, I paid out of pocket for private transport to move the vehicle to my home in Newnan, GA, since Ford could not confirm coverage for towing to my home dealership. As of August 12, 2026, NHTSA materials still list the remedy for 25S75 as under development. My vehicle remains inoperable with no…”

“Window actuator does not properly open or close passenger window to open door properly, which is a safety risks to a child. Window could shatter because window will not roll down the inch or so to pull the door open. In order to open the door, the window will shake vibrantly and risk of a child of a possible window shatter. Ford says this is a normal wear and tear and it’s at owners cost to replace. To me that’s unacceptable.”

“I am submitting a safety complaint regarding my Ford vehicle’s infotainment screen failure, which has been identified under a recall but currently has no available remedy or repair timeline. When the screen goes blank or becomes unresponsive, I lose access to critical safety features, including the rearview camera, which is federally required. This significantly increases the risk of accidents while reversing, especially in areas with pedestrians. The system also affects access to navigation, hands-free communication, and important vehicle alerts, forcing me to either drive without these features or become distracted trying to compensate. Although Ford has acknowledged this issue, there is no clear timeline for a fix, and no accommodations have been provided. I am expected to continue driving a vehicle that does not meet expected safety standards, which puts both myself and others at risk. I rely on my vehicle daily, including transporting passengers, and the lack of a functioning safety system is a serious concern. The absence of communication and support from Ford regarding a resolution is also concerning. I respectfully request that NHTSA investigate this…”

“The digital gauge cluster where it shows sensitive information is a blacked out screen. I took it an automotive shop to investigate the issue. They ran a diagnositic and confirmed the screen is receiving power, fuses are good, but the screen is not powering up. I cannot view the digital speed, fuel gauge, mileage, access GOAT modes, view tire pressure, view oil life, and other critical data, etc. This first occured a few months ago and would randomly turn back on, but not the screen is black more than it is on. Luckily I am able to track the fuel gauge (miles to empty) on the infotainment screen.”

“The contact owns a 2021 Ford Bronco. The contact stated that while driving at an undisclosed speed, the parking assist fault warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed with a failed wiring harness. The contact was informed that a wire from the wiring harness was burned. In addition, the contact was informed that if the wire continued burning it might start a fire. The vehicle was repaired. The contact was informed that the repair was not covered under warranty. The manufacturer was made aware of the failure, and a case was filed. The claim for the repair was denied. The failure mileage was approximately 28,000.”

“I received an alert on the dash stating there was an issue with the blind spot monitoring/rear cross traffic system. It was erroring off and on for that entire drive. When I got home, I googled the issue and it appears it's a known issue with '21 and some early '22 broncos where they factory installed the blind spot module wiring harness too close to the rear bumper. Over time, the wires rub and eventually rub bare and corrode or short out. I went out to take a look and sure enough, I had rubbed through on the driver side (photo) and the passenger side was nearly rubbed through. I have an extended warranty and it's at the dealership today. This is a manufacturing defect and should be covered (even if out of warranty) in my opinion. We will see what kind of story the dealer can come up with to wiggle out of it being covered under warranty.”