1997 Ford Contour engine and engine cooling problems

“BOUGHT A 1997 FORD CONTOUR AND 4 DAYS LATER THE HEAD GASKET BLEW. AFTER BEING IN SHOP OVER A MONTH AND MANY OTHER PROBLEMS REPAIRED I FINALLY GOT CAR BACK AND THE VERY NEXT DAY THE HEAD GASKET BLEW AGAIN WITHIN 2 MILES FROM MY HOUSE. *TR”

“INCIDENT LIKE MANY OTHERS I HAVE HAD MY 1997 FORD EXPEDITION XLT BLOW A SPARK PLUG OUT OF THE CYLINDER HEAD. THE VEHICLE WAS RUNNING FINE AND TROUBLE FREE WHEN A POP FROM UNDER THE HOOD AND A LOUD BANGING NOISE CAME FROM THE ENGINE HEAD. THE VEHICLE WAS TOWED TO THE REPAIR SHOP ; WHO IN TURN CALLED THE LOCAL FORD DEALER. THE REPLY WAS THEY NEVER HEARD OF THIS PROBLEM BEFORE. MY LOCAL SERVICE TECH SAID THE REPAIR KIT ALONE WOULD COST $1,000,00. TO REPAIR IT HE SAID THAT FORD HAD ONLY USED 3 THREADS IN THE HEAD THAT FAILED, BUT ARE NOW REPLACING THEM WITH A 7 THREAD HEAD., THIS TELLS ME THAT THEY ARE VERY AWARE OF THE PROBLEM BUT ARE WILLING TO LEAVE THEIR CUSTOMERS OUT TO DRY.. I GUESS THE SCARY PART ABOUT THAT IS I STILL HAVE 4 MORE 3 THREAD SPARK PLUG HOLES TO WORRY ABOUT BLOWING OUT,.I ABSOLUTELY FEEL THIS SHOULD BE THE RESPONSIBILITY OF FORD MOTOR COMPANY WHO IS LOOKING FOR THE AMERICAN PUBLIC TO BUY IT'S TRUCKS. DAMAGE RESULTING IT WILL COST ME AS LITTLE AS $2,500.00 TO REPAIR THE CURRENT PROBLEM ( AND NO GUARANTY IT WON'T HAPPEN AGAIN). OR UP TO $5,500.00 TO REPLACE THE BUILT TOUGH 5.4 TRITON ENGINE. *TR”

“I HAVE 1997 FORD CONTOUR SE. I HAVE HAD SEVERAL PROBLEMS WITH IT, CHECK ENGINE LIGHT COMES ON CONSTANTLY, RADIATOR LIGHT COMES ON CONSTANTLY, RUNS POORLY. I HAD ALL CHECKED WHEN THEY HAPPEN ON MULTILPLE OCCASIONS. AFTER DOING SOME RESEARCH ON THE INTERNET, I FOUND THAT THERE MAY BE A PROBLEM WITH THE WIRING HARNESS IN THE ENGINE COMPARTMENT. I WAS TOLD BY A FREIND THAT HE HAD HEARD OF A PROBLEM LIKE THIS AND FORD WAS FIXING THEM, AND I SHOULD CALL THE DEALER. I CALLED THE DEALER AND THEY CONFIRMED THERE WAS A RECALL BUT BASED ON MY VIN I WAS NOT INCLUDED DUE TO THE AGE OF MY CAR. THIS WAS DONE AT BRANDON FORD AROUND THE JULY/AUGUST TIME FRAME. THINKING THAT I HAD TO DO THE REPAIR MYSELF, DUE TO THE COST AT THE DEALERSHIP (OVER $3000.00), I STARTED LOOKING FOR PARTS MYSELF ON THE INTERNET. THERE I FOUND THE RECALL/EXT. WARRANTY INFO. 99M03 AND IN THIS IT STATES 10 YEARS OR 100,000 MILE. I AGAIN GOT HOPE THAT MAYBE THEY HAD MISSREAD THE RECALL AT THE DEALER SHIP. I THEN RETURNED WITH VIN AND THE INFO 99M03 IN HAD AND ONE OF THEIR SERVICE ADVISERS CONFIRMED THAT IT SHOULD BE COVERED. I THEN MADE AN APPOINTMENT FOR THE NEXT DAY TO DROP THE CAR OFF AT 8:30AM TO HAVE…”

“I RESPONDED TO A SERVICE ADVISORY ABOUT A FAULTY BLOWER FAN SWITCH. THE SWITCH WAS REPLACED BUT IT WAS APPARENTLY REPLACED WITH ANOTHER FAULTY SWITCH WHICH FAILED. I HAD THE FAN REPLACED AT A LOCAL SERVICE STATION TO THE TUNE OF $192.64. FORD WOULD NOT REPLACE THE FAULTY FAN SWITCH. *NM”

“I BELIEVE ALL 1997 FORD CONTOURS SHOULD BE RECALLED, OVER THE PAST 3 YEARS I HAVE REPLACED THE CLUTCH, WATERPUMP, BLOWER MOTOR, BOTH LOWER CONTROL ARMS, BUSHINGS, SWAY BARS, WHEEL BEARINGS, FRONT & REAR BRAKES AND ROTORS(BOTH TWICE!!!!), AXLE, 2 OXYGEN SENSORS, CATALYTIC CONVERTER, EGR VALVE, COIL SPRINGS, BATTERY, BALLJOINTS, DOOR LATCH, ALMOST ALL OF THE FULL FRONT SUSPENSION!!!! THERE ARE MORE PARTS THAT I HAD REPLACED BUT I CAN'T REMEMBER ALL THE NAMES OF THE PARTS THERE ARE TOO MANY!! MY CHECK ENGINE LIGHT WILL NOT TURN OFF, SEAT BELT LIGHT WILL NOT TURN OFF, SHORT IN THE DRIVERS SIDE POWER WINDOW, THE ENGINE WILL (REV) UP BY ITSELF WHEN IT'S IN GEAR AND WHEN IT'S NOT, SHORT IN THE DRIVERS SIDE POWER SEATS, WATER LEAKAGE IN THE TRUNK, A/C LEAKS ONTO THE PASSENGER SIDE FLOOR, ALL DOORS SQUEAK NO MATTER WHAT YOU DO, CARPET IS FALLING OUT, HORN WILL NOT WORK MOST OF THE TIME, SAME FOR THE CRUISE CONTROL, WINDSHIELD WIPER SPRAYER DOES NOT WORK, KNOCKING NOISE COMING FROM THE ENGINE, ENDED UP IN VERY BAD DEBT BECAUSE OF THIS AND NO ONE WILL TAKE IT, I STILL OWE MONEY ON THE PIECE OF CRAP. CONTACTED FORD MOTOR AT ONE TIME REGARDING ALL THE PARTS I REPLACED AFTER…”

“NAR 06/19/2003. *MR THE CONSUMERS WATER PUMP HAD BROKEN AND TO HIS SURPRISE THE MECHANIC DISCOVERED THAT THE PUMP WAS MADE OF PLASTIC, IN WHICH THEY ARE USUALLY MADE OF METAL. THE CONSUMER BELIEVED THAT FORD SHOULD RECALL ALL CARS MADE WITH PLASTIC PUMPS AND REPLACE THEM WITH METAL ONES. *CB *JB”