1998 Ford Contour fuel system, gasoline problems

“1998 FORD CONTOUR. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE LINE CORROSION. *SMD THE CONSUMER STATED THE BRAKES THE FAILED. THE REPAIR SHOP, STATED THERE WAS NO BRAKE FLUID IN THE RESERVOIR. THE CONSUMER ALSO STATED THE GAS LINE LEADING TO THE TANK HAD TO BE REPLACED, DUE TO CORROSION. *JB”

“THE ENGINE WIRING HARNESS WHICH CONNECTS TO THE VEHICLE'S MAIN POWER SUPPLY BOX HAS WIRING FOR WHICH THE INSULATION COMES OFF EXPOSING LIVE, BARE WIRES. THIS LEADS TO SHORTS IN THE ELECTRICAL SYSTEM WHICH AFFECTS DRIVABILITY (ENGINE RUNS ERRATICALLY AND AFFECTS THE ELECTRIC FUEL PUMPS OPERATION) AND COULD LEAD TO A VEHICLE FIRE IF THE WIRING SUFFERS CATASTROPHIC FAILURE. IT GOES WITHOUT SAYING THAT IF THE CAR'S FUEL SUPPLY OR ENGINE CONTROL SYSTEMS FAIL, THE DRIVER MAY LOSE CONTROL AND BECOME INVOLVED IN A CRASH OR COLLISION. FORD DOES NOT SALE REPLACEMENT PARTS NOR ARE PARTS AVAILABLE ON THE SECONDARY MARKET. THE PART NUMBER FOR THE WIRING HARNESS ON MY CAR IS F8RZ14289CA. FORD SHOULD BE REQUIRED TO REPLACE THESE DEFECTIVE HARNESSES. *TR”

“TL* THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT STATED THAT WHEN DISPENSING FUEL INTO THE FUEL TANK, THE AUTOMATIC FUEL NOZZLE WOULD SHUT OFF AT ANY FUEL CAPACITY LEVEL. THE FAILURE WAS A CONTINUOUS OCCURRENCE WHEN DISPENSING FUEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY INFORMED THE CONTACT THAT THE FUEL PIPE FLAPPER VALVE WOULD NEED TO BE REPLACED. THERE WAS A MANUFACTURERS VOLUNTARY RECALL (MANUFACTURER RECALL NUMBER: 01M04) YET THE MANUFACTURER INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 200.”

“FUEL SPIT-BACK WHILE REFUELING. TOOK TO FORD DEALERSHIP AND SINCE THE EXTENDED COVERAGE FOR THE FUEL PIPE FLAPPER VALVE EXPIRED 5 MONTHS AGO THEY WILL NOT REPAIR. FORD WANTS $300 TO REPAIR. MY CAR ONLY HAS APPROXIMATELY 88,800 MILES AND I DO NOT HAVE $300 TO REPAIR. I CALLED FORD IN MICHIGAN AND THEY SAID THE SAME THING AND EMPHASIZED THE IMPORTANCE OF TAKING CAR TO FORD DEALERSHIP FOR REPAIRS. I TOOK CAR TO FORD IN MISSISSIPPI IN 2002 AND NO MENTION OF RECALL WAS MADE. FORD, IN MY OPINION, SEEMS TO BE OF THE MIND "DO NOT FIX IT IF IT IS NOT BROKE". WELL IT IS BROKE NOW AND IF COVERAGE EXPIRED 5 MONTHS AGO THAT IS NOT A LONG PERIOD OF TIME AND FORD SHOULD PAY FOR THE REPAIR OF THE FUEL PIPE FLAPPER VALVE AS THEY KNOW IT IS DEFECTIVE. WHEN I GET GAS THE FUEL SPILLS ON THE GROUND CAUSING HARM TO MY FAMILY, PASSENGERS IN THE CAR, THE GENERAL PUBLIC AND MYSELF. *TR”

“FOR SEVERAL YEARS VEHICLE MADE A BANG WHEN GOING OVER A SPEED BUMP JUST ASSUMED IT WAS BUMPER ON SUSPENSION. TODAY I LOOKED UNDER VEHICLE FOUND THAT THE GAS TANK STRAP HAS COMPLETELY RUSTED AWAY AND FROM THE LOOKS OF IT HAS BEEN GONE FOR A LONG TIME. THE BANG MIGHT HAVE BEEN THE TANK. VEHICLE HAS BEEN GARAGED WITH 61K. *JB”

“INTERMITTENTLY WHEN THE GAS PEDAL WAS APPLIED, THE VEHICLE FAILED TO ACCELERATE. THIS OCCURRED BECAUSE OF AN OBSTRUCTION IN THE FLOW OF FUEL TO THE ENGINE. THE DEALERSHIP HAS SERVICED THE VEHICLE 5 TIMES. THEY HAVE REPLACED THE FUEL PUMP, THE FILTER AND THE OXYGEN SENSOR. THE PROBLEM STILL EXIST. THE DEALERSHIP REFUSED TO SERVICE THE VEHICLE ANYMORE BECAUSE THEY INDICATED THEY HAVE DONE ALL THEY COULD DO TO CORRECT THIS PROBLEM. *NM THE VEHICLE LEAKED OIL OVER THE ENTIRE ENGINE, THE FUEL PRESSURE DROPPED WHEN THE VEHICLE WAS DRIVEN ON MOUNTAINOUS AREAS, A SHORT WAS FOUND, AND WIRES WERE FOUND CHAFFED. *SC *JB”