1998 Ford Contour service brakes, hydraulic problems

“1998 FORD CONTOUR. CONSUMER WRITES IN REGARDS TO VEHICLE BRAKE LINE CORROSION. *SMD THE CONSUMER STATED THE BRAKES THE FAILED. THE REPAIR SHOP, STATED THERE WAS NO BRAKE FLUID IN THE RESERVOIR. THE CONSUMER ALSO STATED THE GAS LINE LEADING TO THE TANK HAD TO BE REPLACED, DUE TO CORROSION. *JB”

“TL*THE CONTACT OWNS A 1998 FORD CONTOUR. THE CONTACT PURCHASED BRAKESAFE FRONT DISC PADS FOR THE VEHICLE. APPROXIMATELY 30 MILES LATER, A GRINDING AND RATTLING NOISE WAS HEARD AND AN OUTER LINING ON THE PADDING FELL OFF. THE CONTACT TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THE PADS WERE DEFECTIVE. HE PURCHASED NEW PADS, WHICH HE FELT WORKED AS THEY SHOULD HAVE. HE ATTEMPTED TO CALL THE AUTO PARTS STORE FROM WHERE HE PURCHASED THE DEFECTIVE PADS, BUT THEY WOULD NOT ASSIST. HE ALSO CALLED THE CORPORATE OFFICE AND RECEIVED NO ASSISTANCE. THE CONTACT FILED COMPLAINTS WITH THE FEDERAL TRADE COMMISSION AND OHIO ATTORNEY GENERAL. THE SERIAL NUMBER AND PART NUMBER WERE UNKNOWN. THE CURRENT MILEAGE WAS 135,000 AND FAILURE MILEAGE WAS 134,970. UPDATED 06/25/08. *CN THE CONSUMER STATED PASSENGER SIDE CALIPER WAS WARPED AND THE ROTOR WAS DAMAGED. UPDATED 06/25/08”

“DT: VEHICLE STARTED MAKING LOUD NOISES AND THE BRAKES FAILED. CALLER WAS DRIVING ON A HIGHWAY AND HAD TO PULL OFF THE ROAD. CALLER SAID BRAKES DID NOT WORK VERY WELL WHEN SHE TRIED TO GET THE CAR HOME. DEALER SAID THE FRONT LEFT ROTOR BROKE ,AND REAR WHEEL BEARING WORE OUT . MANUFACTURER WILL NOT OFFER ANY HELP.*AK”

“THE BLOWER AND ABS SYSTEM WERE DEFECTIVE. THE ABS LIGHT WAS ON. THE FUSE NEEDED TO BE REPLACED, AFTER INSPECTION WIRING HARNESS WAS FOUND TO BE DEFECTIVE. THERE WAS A RECALL FOR VEHICLES THROUGH 1997. *AK”

“BRAKE FAILURE. ON A 1998 FORD CONTOUR SVT (~118,440 MILES), THE BOLT ATTACHING THE REAR BRAKE CALIPER RESULTED IN A SINGLE POINT FAILURE TO THE BRAKING SYSTEM. *JB WHILE DRIVING NORTH ON US 301, JUST SOUTH OF LAPLATA, MD, I HEARD A POP AND THE CAR FELT AS IF I HAD RUN OVER SOMETHING, BUT NOTHING APEARED IN THE ROAD (FROM THE MIRRORS). LATER WHEN SLOWING WHILE APPROACHING AA TRAFFIC SIGNAL, I HAD NO BRAKES. THANKFULLY I WAS ON A SLIGHT INCLINE AND ABLE TO GEAR DOWN AND USE WHAT LITTLE BRAKES REMAINED TO STOP THE CAR AND CRAWL IT TO A PARKING LOT. AFTER HAVING THE CAR TOWED IN, MY MECHANIC TOLD ME THAT ONE BOLT ATTACHING ONE OF THE REAR CALIPERS HAD SHEARED OFF CAUSING THE LOSS OF BRAKING POWER ON THE CAR. THE CAR DID NOT LOSE ANY BRAKE FLUID DURING ALL OF THIS.”

“HAD VEHICLE TAKEN IN FOR NORMAL PMI (PREVENTIVE MAINTENANCE INSPECTION) SERVICING AND DURING INSPECTION-- THE REAR PCRV (PRESSURE CONSCIOUS REDUCING VALVES WERE FOUND TO BE CORRODED AND LEAKING. THIS VEHICLE IS OPERATED IN WI (SALT IS USED ON ROADWAYS UP HERE). THERE IS A RECALL OUT FOR THIS ITEM, BUT IT COVERS NON-ABS VEHICLES ONLY....... MY VEHICLE HAS THE ABS SYSTEM. IT LOOKS LIKE THE RECALL WASN'T EXPANDED FAR ENOUGH..... PROBLEMS ARE STILL OUT THERE!!!!! THE TECHNICIAN THAT DID THE REPAIR ON THE CAR SAID THAT HE HAD DONE THAT SPECIFIC RECALL ON OTHER VEHICLES MULTIPLE TIMES, AND STATED THAT THE REPLACED PCRVS ON MY CAR WERE THE *OLD STYLE* VALVES..... THAT IS WHY HE WAS CONCERNED AND RECOMMENDED I REPLACE THE PCRVS ASAP--- WHICH WAS DONE THAT DAY. THERE WAS NO ACCIDENT/INJURY/FATALITY INVOLVED IN THIS INCIDENT OBVIOUSLY. BUT THERE COULD HAVE BEEN. THE RELATED RECALL INFORMATION THAT I'M REFERRING TO IS AS FOLLOWS: NHTSA CAMPAIGN ID: 00V075000. *JB”