2000 Ford Contour fuel system, gasoline problems

“TL* THE CONTACT OWNS A 2000 FORD CONTOUR. THE CONTACT STATED THAT AFTER REFUELING, A STRONG ODOR OF FUEL WAS EMITTED FROM THE VEHICLE. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THAT THE FUEL TANK WAS LEAKING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND THE CONTACT WAS INFORMED THAT THE FILLER PIPE GROMMET WAS LEAKING. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 00V350000 (FUEL SYSTEM, OTHER:STORAGE:TANK ASSEMBLY). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 173,000.”

“TL*THE CONTACT OWNS A 2000 FORD CONTOUR. THE CONTACT STATED THAT WHEN PUTTING FUEL IN THE VEHICLE, THE FUEL WOULD SPILL ONTO THE GROUND. THE DEALER STATED THAT THE FUEL FILTER GROMMET FAILED. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE VEHICLE WAS NOT INCLUDED IN RECALL 00V350000 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY). THE CURRENT AND FAILURE MILEAGES WERE 67,400.”

“CAR ACCELERATION WAS SLUGGISH WHEN BRAKE WAS APPLIED,A WEEK LATER ENGINE WOULD KILL WHEN DRIVING. CHANGED AIR FILTER,OIL,AND FUEL LINE WAS CLEARED. A MONTH LATER SAME THING IS HAPPENING. MECHANIC SAYS MAY NEED NEW FUEL PUMP,BUT NOT SURE THAT WILL CORRECT PROBLEM. *TR”

“MY 2000 FORD CONTOUR SE STARTING ACTING LIKE THERE WAS NO GAS AT AROUND 1/4 TANK. THIS CONTINUED EVERY TIME MY CAR GOT TO 1/4 TANK. MECHANIC REPLACED FUEL FILTER $54.90 FOR FILTER AND DIAGNOSTIC ON 3/13/07. IT STILL STUTTERING, HESITATED AND NOW WAS STALLING. MECHANIC REPLACED FUEL PUMP $297.22 ON 3/28/07. THE PROBLEM PERSISTED AND NOW IT WAS HAPPENING AT 1/2 TANK. ONCE SUMMER HIT, IT WAS WORSE WITH THE A/C. BETWEEN MARCH AND JUNE 2007, MECHANIC REPLACED PUMP ONCE AND FILTER TWICE. ON 6/27/07, CAR STALLED AND WOULD NOT RESTART, TANK WAS AT 1/2. MECHANIC REPLACED INTAKE MANIFOLD RUNNER CONTROL UNIT AND THE PROBLEM REMAINED. THE PROBLEM CONTINUED WITH HESITATING AND STALLING ESPECIALLY UPHILL. ON 8/21/07 REPLACED ALL THE SPARK PLUGS AND WIRES $234.90. THE PROBLEM CONTINUED. MY MECHANIC IS AT HIS WITS END. THE CODE ON THE CHECK ENGINE LIGHT IS ALWAYS THE SAME. ON 10/26/07, TOOK THE CAR BACK TO MY MECHANIC WHO HAD TO REPLACE THE INTAKE MANIFOLD RUNNER CONTROL UNIT AGAIN. DECIDED TO TAKE MY CAR TO A DIFFERENT MECHANIC DUE TO MY CURRENT ONE NOT FINDING THE PROBLEM. REPLACED 2 OXYGEN SENSORS THIS WEEK (11/7 AND 11/9) ONE UPSTREAM AND ONE DOWNSTREAM. THE CHECK ENGINE…”

“TL*THE CONTACT OWNS A 2000 FORD CONTOUR. THE CURRENT MILEAGE WAS 134,112. THE FAILURE MILEAGE WAS 114,112. WHILE DRIVING 70MPH THE VEHICLE HESITATED A FEW TIMES AND THEN THE ENGINE DIED. THE VEHICLE WAS RESTARTED AFTER 15 MINUTES. THE DEALER STATED THE FUEL TANK HAD FAILED. THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER 00V350000 (FUEL SYSTEM, OTHER: STORAGE: TANK ASSEMBLY).”

“DT*: THE CONTACT STATED THAT THE VEHICLE'S GAS TANK STRAP DETACHED ON 07/01/06. A STRAP WAS OBSERVED HANGING FROM UNDER THE VEHICLE WHILE PARKED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHO DETERMINED THAT THE RIGHT HAND FUEL TANK ASSEMBLY STRAP HAD BECOME DETACHED. THE INDEPENDENT REPAIR SHOP CONTACTED THE DEALER WHO CONTACTED THE MANUFACTURER TO ORDER FUEL TANK ASSEMBLY STRAP. THE MANUFACTURER DETERMINED THAT THE FUEL TANK ASSEMBLY STRAP WAS ON BACK ORDER AND THAT THERE WAS NOT A SPECIFIC DATE WHEN THE PART WOULD ARRIVE.”