2017 Ford Escape vehicle speed control problems

“NHTSA Complaint SummaryVehicle: 2017 Ford Escape SEEngine: 1.5L EcoBoostVIN: [XXX] Defect: Engine Block Design Flaw / Coolant IntrusionTechnical Description of the Issue:My vehicle is experiencing a well-documented manufacturing defect specific to the 1.5L EcoBoost engine. The engine block was designed with a "v-groove" between the cylinders that is prone to structural failure. This allows engine coolant to leak into the combustion chambers (coolant intrusion) and allows engine oil to contaminate the cooling system. My vehicle currently exhibits "milky," tan-brown sludge in the coolant reservoir, confirming that oil and coolant are cross-contaminating due to internal engine failure.Extreme Safety Hazards and Dangers:This defect creates several critical safety risks for the driver, passengers, and other motorists:Sudden Loss of Power at High Speeds: The mixing of oil and coolant destroys the engine’s ability to lubricate internal bearings. This can lead to a catastrophic engine seizure while the vehicle is in motion, causing an immediate loss of power and power steering, which creates a high risk of collisions on highways.Engine Fire Risk: When coolant enters…”

“Coolant is leaking into the cylinders, causing misfire. Per this document that you guys posted: "Customer Satisfaction Program 21N12", this is a known manufacturing defect in the engines that are in the model of car that I am driving currently. This is a safety issue and an environmental issue. Coolant gets into the cylinders and burns, emitting into the atmosphere. But the coolant also runs low, and the engine could overheat or catch on fire. The mechanic is estimating currently that the repairs to either change the head gasket or take the engine apart and rebuild it will cost around 7-9k, money we don't have. Ford should fix this manufacturing defect at not cost to us, as their CSP 21n12 document states. The only caveat is that the car has 98k miles on it while the cutoff for these repairs ends at 84k miles.”

“I was driving on I 95 and my check engine light came on, then the transmission light came on followed by No hill assist light.As I was driving home all of a sudden without warning my SUV dropped to 10 miles an hour while driving at at speed of 55 miles per hour.. For safety reasons I pulled over on to the shoulder, shut the SUV off a waited , and then I restarted the engine. The same lights came on and again I couldn't drive over 10 miles an hour. After sitting for over 5 months waiting for a recall because Ford said that's the only way they will fix the problem. I hired someone to look at my SUV, I called the Ford Hotline and asked if there was a recall, Because I remember 2 months before it broke down someone came out to my home to fix the bushings that were also being recalled. I was told no , but was advised to wait to see if there would be a recall. Within the last 2 weeks I asked a mechanic to look at my SUV, I was told the issue is an electrical problem, something about control module/ that caused the computer system to fail. The compute is telling the SUV that it's in park., that's why the SUV went into limp mode and won't go over 10 miles per Hours the…”

“The contact owns a 2017 Ford Escape. The contact stated that while driving 25 MPH, the vehicle lost motive power. The vehicle was slow to accelerate. There was white smoke coming from the exhaust, with the check engine warning light illuminated and flashing on and off. The vehicle was taken to a local dealer, where it was diagnosed and determined that there was a crack in cylinders #3 and #4. The dealer recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 136,000.”

“My son was driving this car home from school and while going through a busy street, the car suddenly buckled and stalled and he was almost t-boned. Thankfully he was not hit. We later found out that this vehicle was assembled in a plant that has a known line issue with their engine blocks. This issue caused one of the cylinders to crack and fluid to leak in causing the issue that almost caused the accident. We were made aware that this is a known issue by our service person. Ford is aware of it as they have issued CSPs and TSPs regarding the issue but have yet to issue a recall and will not cover repair costs or offer to fix vehicles before they have the issue. Ford should have a safety recall to prevent possible accidents as these vehicles age and the problem occurs more regularly.”

“The contact owns a 2017 Ford Escape. The contact stated that while operating the vehicle and depressing the accelerator pedal, the vehicle would not properly accelerate. The contact stated that the check engine warning light remained illuminated. The contact stated that the vehicle hesitated while accelerating and occasionally surged forward while depressing the accelerator pedal. The vehicle was taken to the local mechanic who was unable to determine the cause of the failure. The vehicle was not repaired. The manufacturer and local dealer were not yet contacted. The failure mileage was 60,000.”