2021 Ford Escape engine problems

“Description of Defect & Safety Risk: Complete structural failure and collapse of the entire 3-part powertrain mounting system (right engine mount, left automatic transmission mount and rear lower engine torque strut mount). The severe defect was discovered at a mere 27,000 original miles by a certified independent technician fount the broken motor mounts during inspection, and I confirmed experiencing excessive, violent vibrations inside the vehicle cabin radiating heavily through the chassis. Total failure of these primary structural supports creates an immediate under-hood hazard. Severe engine shifting or total powertrain displacement while in motion can pinch fuel lines, sever electrical wiring harnesses, or snap CV axles. This poses an imminent risk of sudden highway propulsion loss or loss of vehicle steering control. Consumer notes that Ford TSB 20-2215 identifies an identical 3-part powertrain mount failure on this exact vehicle platform.”

“My escape would not change gears and the escape would not reverse it was also pulling back and accelerating in speed to the point I could not control it in traffic. My safety and the safety of my mother were greatly affected as the escape was malfunctioning in traffic and I could not control the gears. The alert on the escape came up and it stated: The powertrain control system has detected one of the transmission clutches did not apply within the expected time as expected. Some transmission gears may not being available resulting in delayed or harsh shifts into another gear. Additional alerts that may provide additional information may accompany this alert. I took it to dealership and they told me it would need a transmission over haul. Once repairs were completed I brought it back home and had to take the escape back to the dealership because it started to pull back again and for the second time the dealership told me the escape would need a second transmission overhaul”

“Complaint to the National Highway Traffic Safety Administration (NHTSA) I am filing this complaint regarding an unresolved safety recall on my vehicle. This recall has remained open for more than one year, yet no remedy has been made available. Despite the manufacturer acknowledging the safety defect, I continue to operate a vehicle that presents significant safety concerns because the defect has not been corrected. The recall has caused my vehicle to experience severe drivability issues, including engine failure, excessive rough idling, and violent shaking while the vehicle is operating. These conditions create an increased risk of the vehicle stalling unexpectedly, reducing my ability to safely operate the vehicle and placing myself, my passengers, and other motorists at risk. Additionally, because of the unresolved recall condition, my vehicle is unable to pass the required state safety inspection. This has left me with a vehicle that I cannot fully utilize or register while I continue waiting for the manufacturer to provide a repair. It is unreasonable for consumers to wait more than a year for a safety recall remedy while continuing to experience hazardous…”

“My car was at only 55,000 miles, there was a weird shuddering and my RPMs were very jumpy. It almost felt like my car was going to stall out. I took it in to the ford dealership and I had to get my Torque Converter replaced. I had no dash lights on or any other problems. I got it replaced, but my car still feels shaky while at low speeds. Apparently it’s a very common problem in this car.”

“On XXX I was driving my 2021 Ford Escape for 10 minutes before I stopped at Sheetz gas station on [XXX]. I ran into the building to withdraw cash from the ATM leaving my fiance and dog in the car while it sat idle. Upon exiting the building about 30 seconds to a minute later, I witnessed smoke coming up from the hood of my car. My fiance and Dog quickly evacuated the car as we saw flames emerging. I ran inside to get assistance from the workers and they brought out fire extinguishers. The attempt to extinguish the flames was unsuccessful and the front of the car quickly went up. Police and fire department were called and they showed up about 10 minutes later to handle the situation. Reports from the officer, fire department and the Sheetz assistant were taken. I do not have access to those. My car insurance is covering the cost of the vehicle and a 7 day car rental. They are not covering the loss of both mine and my fiance's cell phones.”

“MY VEHICLE HAS HAD A FUEL INJECTOR RECALL SINCE 07/2025. MY CAR HAS GRADUALLY STARTED TO IDLE AND DROP RPMS. IT STARTS WHEN THE VEHICLE WAS ONLY IN PARK AND NOW IT IS HAPPENING WHEN I AM IN DRIVE AND FOOT IS ON THE BRAKE. I AM NOT SURE WHAT TO DO BECAUSE OF THE OPEN RECALL WITH NO REPAIR OPTIONS IN SIGHT ALMOST A YEAR LATER.”