2021 Ford Escape service brakes problems

“I am filing this safety complaint on behalf of myself and my wife, [XXX] , the primary driver of our 2021 Ford Escape PHEV, with active under Recall 25SC4 (no remedy available). The vehicle has experienced 8+ sudden complete shutdowns during normal driving since February 2026, always during EV-to-hybrid mode transition, always without prior warning. The only warning is a brief sound like air escaping immediately before shutdown. At shutdown: engine cuts completely, steering wheel locks rigid and cannot be turned, brake pedal locks hard and cannot be depressed, gear selector locks in Drive and cannot be changed. The driver has zero ability to steer, brake, or move the vehicle. Must activate hazards and wait 1-5 minutes for restart while immobilized in an active traffic lane. Incidents occurred: (1) February 2026: multiple times, dealer retained vehicle 5 days, found nothing. (2) Early April 2026: multiple times, including one witnessed by a police officer who directed traffic around immobilized vehicle. Dealer kept 3 days, blamed the original Ford-supplied charger. Replacement did not fix defect. (3) May 1, 2026: 4 times in one day with my wife only in the car,…”

“When putting the car in reverse the brakes make an awful Screaming noise. It sounds like they are not releasing. Then when you go in drive and want to stop it doesn't want to. It is not all the time but more so then not.”

“The contact owns a 2021 Ford Escape. The contact stated that while shifted into reverse and depressing the brake pedal and attempting to slow down, there was an abnormal sound coming from the rear wheels. No warning light was illuminated. The vehicle was taken to a local dealer, where it was diagnosed with asbestos in the brake fuse. The vehicle was repaired; however, the failure progressed. The manufacturer was not made aware of the failure. The failure mileage was unavailable.”

“1 Brakes are making noise all times when in slow motion the brake paddle depressed ether is moving forward or reversing the repairs did not fix the problem. 1. Left Taillight show the when the vehicle is expose to water from rain or washed, evaporation and condensation will occur creating a film of running down inside of the assembled taillight and will last for days sometimes. That also cause the dimming of the light from the brakes and from turning light. As driver I am concerned that the dimming of the light can become a safety issue when in transit for diminishing of visibility for other drivers behind of this vehicle.”

“I have had a problem with a loud moaning noise from the brakes when placing the car in reverse. I have reported this and had my car into the Ford dealer on the following occasions: December 28, 2022, November 24, 2023, March 5, 2024, June 6, 2024 and October 16, 2024 The dealer is Tasca Ford at 900 Central Park Ave in Yonkers, N.Y 914-377-8100. I was advised that SSM 52515 was issued by Ford but that they have no solution for this problem. I also see TSB23-2308 referenced on my service receipts. I cannot believe that Ford has no solution for this problem that they have known about for at least two years. I have escalated this to Ford Corporate on November 19, 2024 and have received no response from their main office.”

“The contact owns a 2021 Ford Escape. The contact stated while reversing, there was a loud screeching sound coming from the rear of the vehicle. The vehicle was taken to the local dealer who performed an unstated service on the vehicle, but the failure persisted. No further information was available. The manufacturer was contacted but no assistance was provided. The contact was informed of an Extended Service Warranty however, the vehicle was not included. The failure mileage was 1,500.”