1998 Ford Explorer visibility problems

“TL* THE CONTACT OWNS A 1998 FORD EXPLORER. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 30-70 MPH, THE VEHICLE WOULD LOOSE POWER BUT THE ENGINE WOULD CONTINUE TO RUN. THE VEHICLE WOULD EVENTUALLY STALL BUT WAS ABLE TO BE RESTARTED AFTER SEVERAL MINUTES. IN ADDITION, THE WIPER BLADES WOULD ALSO FAIL AND WOULD NOT OPERATE AS THEY SHOULD WHEN INCLEMENT WEATHER AROSE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THEY ADVISED THE CONTACT THAT THE WIRING IN THE ENTIRE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.”

“THE "BLEND DOOR ACTUATOR" THAT CAME WITH THE VEHICLE IS DEFECTIVE AND HAS BEEN REPLACED WITH A NEW IMPROVED PART (F87Z-18471-DA) AT THE CUSTOMER EXPENSE. THE OLD PART WHEN IT FAILS CAUSES A SAFETY ISSUES BECAUSE YOU CAN NOT DEFROST THE FRONT WINDOW UNTIL THE PART IS REPLACED. THIS SHOULD BE A "RECALL" THAT FORD SHOULD HAVE TO PAY FOR. I HAVE DONE SOME LOOKED INTO THE ISSUE AND MANY VEHICLES (1998 FORD EXPLORER) HAVE HAD THIS SAME FAILURE. *JB”

“I PURCHASED MY 1998 FORD EXPLORER LIMITED FROM MY MOTHER IN JANUARY OF 2006 WITH 68000 MILES ON THE ODOMETER. IN FEBURARY I FIRST NOTICED VEHICLE WAS UNABLE TO DEFROST THE FRONT WINDSHIELD AND DEFOG THE VEHICLES WINDOWS. THE CAUSE OF THE PROBLEM WAS THE CLIMATE CONTROL WOULD SOMETIMES NOT BLOW WARM AIR. THIS WOULD ALSO RESULT IN A VERY COLD INTERIOR. AFTER RESEARCHING THE PROBLEM ON THE INTERNET I FOUND MANY COMPLAINTS REGARDING THE 1996-1998 FORD EXPLORER AND A COMMON PROBLEM WITH THE CLIMATE CONTROL'S AIR BLENDING DOOR BREAKING, MAKING IT IMPOSSIBLE TO REGULATE HEAT AND COLD. THE VEHICLE WAS PARKED UNTIL I COULD DETERMINE IF THIS WAS IN FACT THE ISSUE I WAS HAVING. I HAD NO CHOICE BUT TO PARK THE VEHICLE UNTIL I WAS SURE I HAD NO NEED TO OPERATE THE CLIMATE CONTROL. I WAS INSTRUCTED HOW TO CHECK FOR A BROKEN BLEND DOOR AND INDEED FOUND MINE TO BE BROKEN. I TOOK THE VEHICLE TO A LOCAL FORD DEALER IN CARSON CITY NEVADA AND WAS TOLD THAT DESPITE THE FREQUENCY OF THIS PROBLEM IT WAS NOT A RECALL ISSUE AND WITHOUT A WARRANTY THE COST FOR REPAIR WAS $1100. I WAS ALSO INFORMED THE BROKEN PARTS WERE BEING REPLACED WITH PARTS CONSTRUCTED OF IMPROVED MATERIAL (NYLON)…”

“DT: CONTACT STATED THAT RIGHT AFTER PURCHASING THE VEHICLE HE HAD REPLACE THE BRAKES, TIRES, FUEL FILTER, THE FUEL INJECTION WAS CLEANED , THE ANTI LOCK SENSORS WHERE REPLACED, THE WINDSHIELD WAS REPLACED . THE AIR BAGS ARE ALSO DEPLOYED. WHILE DRIVING THE VEHICLE IT VIBRATES ON THE LEFT SIDE. HE TOOK THE VEHICLE TO A MECHANIC THEY PUT THE VEHICLE ON A RACK TRYING TO LINE THE VEHICLE. IT WOULD NOT LINE UP. THEY FOUND THAT THE BALL JOINTS BAD, ALSO THE MOTOR MOUNTS ARE BROKEN. THE MECHANIC TOLD HIM THAT THE FRAME IS BENT BEYOND REPAIR. *NM”

“1998 FORD EXPLORER, PLENUM DOOR FAILURE, RESULTING IN NO HEAT. CANNOT DEFROST WINDOWS CAUSING SAFETY HAZARD. AFTER MUCH RESEARCH, COMMON PROBLEM WITH FORD EXPLORERS. SHOULD BE A FACTORY DEFECT. GARAGE WANTS $1000 TO FIX. *JB”

“TEMPERATURE CONTROL SYSTEM LOCKED IN COLD AC MODE. SYSTEM WILL ONLY BLOW COLD AIR DUE TO A BROKEN AIR BLEND DOOR. DRIVER CAN NOT DEFROST WINDSHIELD WITH COLD AIR CONDITIONED DEFROST. I BELIEVE THIS IS A SAFETY ISSUE FOR THE DRIVER. THE PROBLEM HAS NOT BEEN FIXED BECAUSE THE COST WILL BE $1200.*JB”