1998 Ford F-150 wheels problems

“OCTOBER 13,2018 ENTIRE WHEEL ASSEMBLY DRIVER FRONT WHEEL CAME OFF WHILE DRIVING ON HWY 64 ROCKY MOUNT NORTH CAROLINA, CAUSE MY TRUCK TO HIT GUARD RAIL, THE AIR BAG DID NOT DEPLOY WHICH CAUSE ME SERIOUS INJURY TO MY NECK, I DID NOT HAVE THE PROTECTION OF THE AIR BAG.”

“TL* THE CONTACT OWNS A 1998 FORD F-150. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC TO HAVE THE TIRES REPLACED HOWEVER, THE CONTACT WAS ADVISED THAT THREE OF THE FOUR RIMS WERE FRACTURED. THE DEALER WAS NOTIFIED OF THE FAILURE, BUT DENIED ANY ASSISTANCE WITH REPAIR TO THE FAILURE. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 190,000 AND THE CURRENT MILEAGE WAS 195,000.”

“1. PURCHASED AND INSTALLED A REPLACEMENT FRONT LEFT BRAKE ROTOR INCLUDING WHEEL STUDS FOR A 1998 FORD F-150 2 WH DRIVE TRUCK V6. PURCHASED FROM ADVANCED AUTO PARTS, PART NAME WEAREVER BRAKE ROTORYH145240, 41801 00563 6. INCLUDED STUDS ON ROTOR ARE IDENTIFIED ON HEAD W726, THEY ARE 12 MILLIMETER THREADS AND APPROXIMATELY 2.25" LONG. 2. FAILURE, WHILE INSTALLING WHEEL TWO STUDS SNAPPED AND BROKE IN TWO AT JUST 60 FOOT POUNDS TORQUE. NUTS WERE TIGHTENED WITH A TORQUE WHENCH IN PROPER SEQUENCE. OBSERVED BOTH STUDS BROKE AT APPROXIMATELY 1.1" FROM TOP OF HEAD OF STUD AND THERE APPEARS TO BE A CAVITY (VOID) OF ABOUT 75% OF THE STEEL FROM THE CENTER OUT WITH ONLY THE RIM (NEAR THREADS) WITH SOLID METAL. 3. REMOVED AND REPLACED BROKEN STUDS WITH THE ORIGINAL EQUIPMENT STUDS FROM THE OLD ROTOR. THE DEFECTIVE STUDS ARE SECURED AND AVAILABLE. *TR”

“TL*THE CONTACT OWNS A 1998 FORD F150 LD. WHILE DRIVING 55 MPH, THE REAR PASSENGER SIDE ALUMINUM RIM BEGAN TO SEPARATE. THE WHEEL LIP RIM DETACHED AND CAUSED A BLOW OUT. THE CONTACT STATED THAT THERE WERE TWO MORE RIMS THAT WERE EXPERIENCING THE SAME FAILURE. THE DEALER HAS BEEN NOTIFIED AND STATED THAT THE CAUSE OF FAILURE WAS DUE TO CORROSION. THE CURRENT MILEAGE WAS 150,000 AND FAILURE MILEAGE WAS 100,000.”

“TL*- THE CONTACT OWNS A 1998 FORD F150. WHILE DRIVING AT 25 MPH THE FRONT WHEEL CAME OFF THE VEHICLE. THE ROAD CONDITIONS WERE CLEAR. THE DEALER WAS UNABLE TO DIAGNOSE THE FAILURE. THE CONTACT STATED THAT THERE WAS RECALL 98V09500/NSA#111PAW FOR THE LUGS:NUTS. HOWEVER, THE MANUFACTURER AND THE DEALER STATED THIS VEHICLE WAS NOT INCLUDED AS PART OF THE RECALL. THE CURRENT MILEAGE WAS 68,000.*AK”

“1998 FORD F150 RIGHT WHEEL FELL OFF. *TS THE VEHICLE STRUCK A DELINEATER POST THEN A EMBANKMENT ON THE NORTH SIDE OF THE ROAD. THE VEHICLE'S RIGHT FRONT A-ARM BROKE, THE LOWER RIGHT DOOR BENT, THE FRONT BUMPER GRILL WAS DAMAGED, REAR GLASS BROKE, POSSIBLE FRAME TWIST/UNDERCARRIAGE DAMAGE (OHIO TRAFFIC CRASH REPORT). *NM”