2016 Ford F-150 power train problems

“I am filing this complaint regarding a serious transmission safety issue with my son's 2016 Ford F-150, which is subject to Ford Safety Recall 26S28 / NHTSA Recall 26V237 and is also within the scope of NHTSA Engineering Analysis EA26001 concerning unintended transmission downshifts. The truck was operating normally before the recall repair. Ford notified us that the vehicle was affected by the transmission recall and instructed us to take it to a Ford dealer. The recall remedy involved reprogramming the powertrain control module with updated software intended to address the transmission-range-sensor problem and prevent unintended downshifts. We took the truck to a Ford dealer and had the recall software update performed. Immediately following the software update, the truck developed severe and abnormal transmission behavior and became essentially undrivable. Among the problems experienced were the truck attempting to start in an incorrect gear, including fifth gear, and extremely abnormal shifting while driving, including an apparent shift from sixth gear directly to first gear – ironically the same type of dangerous and unpredictable transmission behavior…”

“My truck was driving fine since I bought it 9 years ago. Ford sent me a letter saying to come in for a recall (Recall 26S28). I went to my local Ford dealership for the recall work, and after that my truck started driving very poorly. The transmission would shudder, and studder at all RPMs (unsafe at highway speeds). I called the dealership and was given the run around. I was told by the dealership that the 'transmission learning' was reset and that it was fine now. Their fix didn't do anything and the truck still had transmission problems. I then found out that the recall that was performed on my truck was 'paused' due to it causing 'issues'. Ford refuses to tell me why the recall was paused, and insists that the recall did not break my truck (even though it was obviously paused for a reason). After driving it for a few months and it getting worser and worse, I called another branch of the dealership. They told me that my transmission was basically broken now, and that it would be $9000 to replace it. The truck has 72000 miles on it. The truck ran perfectly fine for almost a decade and now the transmission fails after the transmission recall work was done. I…”

“My 2016 Ford F-150 5.0L V8 has experienced repeated failures involving the transmission gear-position system and inability to start. During the most recent incident, I was stopped at a traffic light when a wrench warning illuminated on the dashboard and all transmission gear-position indicators disappeared. The vehicle remained operational but exhibited significantly reduced performance when accelerating. Concerned about the malfunction, I turned off the ignition to attempt a restart. The vehicle would not restart, leaving me stranded. This failure created a serious safety concern because the vehicle could have become disabled in active traffic. Previously, the vehicle experienced a similar no-start condition. An independent repair facility replaced the starter, negative battery cable, and shift lever. Although the vehicle initially operated normally, the problem returned. The repair facility subsequently reproduced the failure and retrieved diagnostic trouble codes consistent with Ford's transmission-related safety recall. The underlying defect remains unresolved. The vehicle is currently undrivable and located at an authorized Ford dealership, where it is…”

“The contact owns a 2016 Ford F-150. The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 26V237000 (Power Train); however, the failure occurred after the recall repair. While starting the vehicle, the transmission started out at 5th gear with the engine revving, and while driving at various speeds, the transmission slammed into gear before accelerating. The vehicle then went into LIMP Mode with the transmission and check engine warning lights illuminated. The vehicle was taken to the dealer, who determined that the lead frame and PCM were normal, but the transmission might need to be replaced. The manufacturer was notified of the failure by phone. The failure mileage was approximately 163,000.”

“The contact owns a 2016 Ford F-150. The contact stated that while driving, the transmission unexpectedly downshifted, the rear wheels locked up, and the vehicle decelerated. The wrench icon was displayed, and the check engine warning light was illuminated. The contact stated that there was an abnormal grinding sound coming from the engine compartment. The contact received notification of NHTSA Campaign Number: 26V237000 (Power Train); however, the part to do the recall repair was not yet available. The local dealer was contacted and confirmed the part was not available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure by telephone. The failure mileage was approximately 116,500.”

“I purchased my truck in XXX. Shortly afterwards as I was driving at approx 45 mph, the rear end just locked up and felt like something had snapped inside the transmission or transfer case. I had an extended warranty which Ford took full advantage of claiming that the rear end had locked up due to a bad 4 wheel drive switch and I knew I was being lied to. They got the extended warranty to pay for they're transmission leadframe recall that they didn't fix. They also added 4 degree pinion angle shims under my leaf springs and claimed that I put them on my truck and I did not, they did. They also lied to me and said they hadn't removed my transmission yet I could see fresh tool marks on every bolt on my transmission. They installed a thermal bypass valve in my transmission, I believe so that they could claim that I had installed aftermarket parts therefore ford isn't liable. Not long after Corning ford rebuilt my rear differential that had been destroyed due to the rear end lock up, I got a check engine light for turbine speed sensor fault. Corning ford denied any recall however bomarito ford in [XXX] confirmed that there was a recall for the lead frame that was…”