2023 Ford F-150 exterior lighting problems

“THE REAR BRAKE LIGHT LED FAILED AND FORD REFUSED TO COVER UNDER THEIR 4/48000 BUMPER TO BUMPER WARRANTY, THERE IS NO DAMAGE TO THE LIGHT ASSEMBLY AND THE FAILURE IS GOING TO COST $1700 TO CORRECT. FOR A LIGHT BULB(LED SO NO BULB) ISSUE, THIS IS FRAUD FROM FORD NOT HONORING COVERAGES AND FOR NOT SELLING A VEHICLE WITH NON SERVICABLE PARTS FOR COMMON FAILURE POINTS”

“The contact owns a 2023 Ford F-150. The contact stated that while driving at an undisclosed speed and activating the passenger’s side turn signal, the turn signal lever started to stick. The contact researched online and located similar failures. The contact stated that the dealer was four hours away and was not notified of the failure. The failure mileage was approximately 55,000.”

“Passenger side vertical LED drivers running light bar is out on 2023 Ford F-150 XLT Supercrew. Have heard and seen many Ford F150 trucks that have had this issue. Faulty LED diod heats and burns the light tube from which the light is generated. THIS IS A VERY COMMON ISSUE, IS A MANUFACTURERS DEFECTIVE PART THAT MUST BE RECALLED AND REPLACED.”

“The driver's side headlamp has a significant amount of shadows within the beam. This is in both the low beam and high beam modes. The shadows are highly visible on the road, and create a significant distraction while driving. This distraction is made significantly worse by the vehicles adaptive headlight system, as the shadows move on the road then you turn the steering wheel. The causes the driver's eyes to focus on the moving shadows, rather than on the road ahead. Additionally, the shadows in the headlamp significantly reduce visibility on the driver's side of the car, making it far more difficult to see animals or debris in the road. The vehicle was purchased new and the issue has been prevalent since the very beginning. Ford customer service will not help. Ford dealers tell me that the see the issues, and it should be that way, but are unwilling to replace the headlamp assembly because the cannot determine the root case (code), and are fearful that Ford will just charge them back for the warrant repair.”

“The turn signal stalk on my 2023 Ford F-150 Lightning intermittently requires excessive force to manually cancel after turns and lane changes. The stalk self-cancels normally roughly 50% of the time, but when the steering wheel does not rotate far enough to trigger automatic cancellation the driver must manually return the stalk to center. The condition is most reliably reproduced when the cabin has been elevated in temperature for an extended period and subsides once cooled. The issue predominantly affects right-hand turns and lane changes. The affected component is the turn signal stalk switch pack (multifunction switch), available for inspection. Diagnostic scanning confirmed DTC B124C stored in the SCCM. Based on my research this code indicates a Turn Indicator Stalk Switch Pack fault. The safety risk is threefold: first, a stalk that does not self-cancel sends false signals to other drivers. Second, manually forcing the stalk back to center diverts driver attention from vehicle control. Third, when the stalk releases under applied force it does so suddenly and without warning, and if the driver's hand is on the steering wheel this can cause an involuntary…”

“2024 Ford F-150 Lightning Complete instrument cluster blackout while driving. Screen goes entirely black intermittently, lasting up to 30 minutes. Occurs while vehicle is in motion. Issue persists even after stopping and restarting vehicle. Loss of speedometer, battery state of charge, warning lights, and all driver information. This creates unsafe driving conditions with no way to monitor speed or critical vehicle systems.”