2014 Ford Fusion Energi seat belts problems

“The contact owns a 2014 Ford Fusion. The contact stated that while wearing the driver's side seat belt, the seat belt failed to retract and was locked. The contact stated that the failure mostly occurred after the vehicle had been parked outside in extreme heat, but the seat belt operated as needed in the morning after the vehicle had been parked in the garage overnight. The contact was unable to secure herself inside the vehicle using the seat belt. There was no warning light illuminated. The contact stated that the failure was related to NHTSA Campaign Number: 16V875000 (Seat belts); however, the VIN was not included. The local dealer was contacted, but the vehicle was not diagnosed or repaired. The manufacturer was contacted and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 65,000.”

“The contact owns a 2014 Ford Fusion Energi. The contact stated that the rear passenger’s and driver’s side seat belts failed to latch securely. The manufacturer was notified of the failure and informed the contact that there were no recalls on the VIN for the failure. The vehicle was not repaired. The failure mileage was approximately 40,000.”

“One of the rear seat belts will lock and not release. After you unlatch it, it doesn’t retract properly. I feel this is unsafe and should be fixed by the manufacturer.”

“I purchased the vehicle used from a local Mercedes dealership (April 2018) with multiple open recalls. One of the recalls was 16S42. On May 2, 2018, the vehicle was brought to a local Ford dealer where they "corrected" the open recalls. In February 2020, my wife was involved in a motor vehicle accident on the interstate. There was a construction zone that brought traffic to a stop and she was rear-ended by an SUV at speeds between 45-60 MPH totaling the vehicle while it was at a stop. She was the only occupant and was wearing her seatbelt at the time of the cash. The airbags did not deploy and the driver seatbelt did not lock causing her head to strike the steering wheel. She didn't remember if she lost consciousness or not, however, she was later diagnosed with a concussion. The vehicle has since been totaled and was taken into possession by the insurance company. I am unaware of any inspection of the seatbelt that was performed after the crash. I do possess photographs of the vehicle. There were no warning lights active prior to the crash.”

“The right front passenger seat belt locks when vehicle is not running or in parked preventing use. Cannot secure passenger before driving. Often happens in warmer weather.”

“The contact owns a 2014 Ford Fusion. The contact stated that while the vehicle was parked and attempting to place the rear driver’s side and center seat in the upright position, the seats failed to move. The contact removed the bottom half of the seat bracket to get the seat in the upright position. The contact was however unable to reconnect the seat belt back in the correct position. The vehicle was not diagnosed nor repaired. The manufacturer was made aware of the failure. The failure mileage was approximate 70,000.”