2013 Ford Fusion Hybrid fuel/propulsion system problems

“I had coolant leaking in my 2013 Ford Fusion SE 1.6L causing a misfire in cylinder 3 from diagnostics code P0303. After going to a repair shop on 3 seperate occasions and paying to fix issues thought to remedy the issue, I had the Ford dealership in Hudson WI look at it while they took care of a recall. They quoted me $9,900 to replace the engine due to a cracked block. It was hard to get a response from the technician and they were really unprofessional towards me when I requested the part numbers. So much time has been spent on this not to mention that I have been without a vehicle for 1.5 years because my inability to cover additional repairs or the cost of a new car. I also lost my job due to my transportation issues, and paid over $19,000 for this vehicle. I wish Ford would issue a recall because this is a very common issue for this make and model. 2013 Ford Fusion SE L4 1.6L (102K miles)”

“Two recalls for this make year and model car had been recalled previously but not for my VIN specifically and the issues are appearing. The first is “doors may open driving” recall on your website and the second is “engine cylinder head may leaks oil” which is also on ur website. Both were recalled for this make and year of the ford fusion but not for my VIN so ford is stating they cannot fix it and want to charge me even for a diagnostic.”

“The purge valve is likely malfunctioning, which affects the fuel system. Yes, it is available for inspection upon request. The malfunction caused the vehicle not to start after pumping gas, potentially leaving me stranded in unsafe locations, which could be hazardous, especially in high-traffic areas or remote locations. The issue has not yet been officially reproduced or confirmed by a dealer or independent service center. No, the vehicle or component has not been inspected by the manufacturer, police, or insurance representatives. There were no warning lamps or messages before the failure. The issue first appeared when the vehicle failed to start immediately after refueling.”

“As I was going down the highway my car started smoking dramatically. There were no warning lights so I assumed it might be a belt. I pulled to the side of the road and opened the hood to find flames coming from the backside of the engine. I have had it in the shop now for the last two months and the initial thought was that the water pump could have caused the issue. However, after that set of repairs it was burning oil. Further investigation has shown that the head is cracked.”

“I’ve received a letter in March regarding this safety recalls and I not been contacted by the manufacturer for any remedy. I have not had this vehicle for a full six months. Now the break fluids leaks, there’s an issue with a gasket, and I cannot longer drive vehicle due to the smell of something burning. The recall states it’s an increasing risk of a crash. I have to search for transportation to and from work because I refuse to cause harm to myself or others. Safety Risk IF THE BRAKE FLUID LEAKS, YOUR VEHICLE MAY EXPERIENCE AN INCREASE IN BRAKE PEDAL TRAVEL TOGETHER WITH A REDUCTION IN THE RATE OF DECELERATION OVER TIME, INCREASING THE RISK OF A CRASH. Ford should provide another vehicle as a loaner until this issue has been resolved.”

“An unknown component of the fuel system is faulty, causing a very strong odor of fuel to enter the cabin upon starting up, as well as when coming to a stop & idling. The manufacturer has not inspected the vehicle, but an automotive technician confirmed the odor and attempted to remedy the problem by replacing the evaporative system lines, with no change. Fuel lines and tank/vent were inspected, with no fault found. The odor can cause a feeling of illness & headache when driving. It is unknown if there is a leak which could lead to a fire. No warning lamps.”