2013 Ford Fusion HybridRecalls, problems, MPG & safety

“While driving a 2013 Ford Fusion Hybrid Titanium (approximately 157,000 miles), the Electronic Power-Assisted Steering (EPAS) system suddenly failed without warning during heavy rain in Philadelphia, PA. I was driving near the riverfront area by [XXX] when the steering immediately became extremely stiff and difficult to turn. No prior warning lights or steering-related symptoms were present before the failure. Due to wet road conditions and the sudden loss of steering assist, I temporarily lost the ability to maneuver the vehicle normally and nearly collided with roadside structures near the river. Considerable physical force was required to maintain directional control and safely move the vehicle. This created an immediate safety hazard to myself and nearby traffic. The vehicle has not been involved in a crash, but the failure created a near-miss situation. My VIN currently shows no open recall for this issue, despite similar steering-system failures reported in comparable Ford vehicles using EPAS.”

“In 2019, my car suddenly began to leak engine coolant. A low engine coolant signal alarmed, the car started to smoke, and then was un-usable. I took it to a Ford dealership, they ran some diagnostics, and determined that the issue was related to a known recall. They repaired the issue and for 5 years, things seemed ok. This April, the engine coolant warning came back on and the car shut down. I inspected the engine coolant revisor and it was extremely low and the check engine light came on. I took the car in to be inspected and it was noted that the hoses and gaskets were corroded. The hoses and gaskets were replaced and that seemed to resolve all of the alarms and check engine light, but weeks later, the low engine coolant light came back on. This week the same Ford dealership determined that there was an issue with the water pump and that it needed to be replaced. I wondered if anyone else with a Ford Fusion experienced water pump issues and there seem to be two class action lawsuits against Ford siting several vehicle models with faulty water pumps. I can submit my water pump replacement receipt when I receive it from the Ford dealership on Monday.”

“The contact owns a 2013 Ford Fusion. The contact stated that while driving at an undisclosed speed, the vehicle failed to respond normally while depressing the brake pedal. Several unknown warning lights were illuminated during the failure. The failure caused the steering wheel to lock up, the brake pedal became extremely firm, and the accelerator pedal became inoperable. Additionally, the exterior lights shut off unexpectedly and the vehicle lost electrical power. The vehicle was safely pulled into a parking lot, and the contact waited for several minutes before restarting the vehicle. The vehicle was restarted; however, 30 seconds after resuming driving the vehicle shut off again. The vehicle was towed to a Ford dealer; however, the mechanics were unable to duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 179,000.”