2012 Ford Fusion suspension problems

“Absolute unacceptable level of rust to the body and frame. Even with regular car washes, sitting for a year covered. It’s literally totalled and I am out of a car. It’s a 2012 with this amount of rust”

“The contact owns a 2012 Ford Fusion. The contact stated while driving at various speeds, the vehicle was shuddering significantly. The vehicle was taken to a tire shop where the tires were rotated; however, the failure recurred intermittently. The contact stated upon starting the vehicle, a message indicating that the power steering was inoperable was displayed, and the steering wheel was seized. The contact turned off the vehicle. The contact stated that upon restarting the vehicle, the power steering became operable. The vehicle was taken to the dealer, where it was diagnosed and determined that the power steering rack, the front stabilizer link, the passenger’s side outer tie rod, and the lower control arm had failed and needed to be replaced. The contact stated that the Power Steering Control Module (PSCM) was previously reprogrammed under NHTSA Campaign Number: 15V340000 (Steering); however, the failure persisted. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 84,529.”

“I was driving to my drs appointment and as I was pulling up to the hospital I saw a message from my dash and my steering wheel locked up and I had to get it towed and then sent to the dealership but since I had made a few of previous attempts to get it fixed with u guys it wasn’t getting no response, so I had to go get it fixed force and I ended up with a bill..”

“This is an open recall that I'm sure has been stated many times, but the dealerships are not accepting the recall or granting it. The power steering aka. Steering assist system failed. Which is an ongoing issue with my vehicle model and year. It has caused me so many "almost" bad accidents and making it so I have lost an incredible amount of income due to my vehicle being down for repair and unsafe to drive and too expensive to fix. Especially when there is a recall about said thing. I need help.”

“The driver power steering system message goes on every so often and I have to turn off and on to reset the light, but my concern is that it’s going to go off as I’m driving, and the fuel mileage as I’m driving it says mileage to empty and one time I was trying to get to the gas station and it hit 0 and it was still going the car, and the suspension makes noise when I go over the bumps and also when I’m reversing and turning the wheel there’s a popping sound from the front it sounds like,”

“My 15 year old permit driver was driving the car and a power steering message flashed. The car became very difficult to steer and very difficult to pull to the side of the road. This could have caused a major accident. I was told when I called there was a recall for this in the past but had been fixed on this particular car. It must not have been fixed well. The car is not technically high mileage by today’s standards.”