2015 Ford Fusion steering problems

“The contact owns a 2015 Ford Fusion. The contact stated that while driving 45 MPH, the messages "Loss of Traction Control" and "Advancetrac Off" were displayed, and the vehicle lost power steering functionality. The contact safely pulled over to the side of the road. The vehicle was towed to the dealer, where it was diagnosed and determined that the steering gear motor had failed and needed replacement. The vehicle was not repaired. The contact associated the failure with NHTSA Campaign Numbers: 15V250000 (Steering) and 19V632000 (Steering). The contact stated that the vehicle was previously repaired under NHTSA Campaign Number: 15V250000 (Steering); however, the recall repair failed to prevent the failure. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 177,000.”

“The contact owns a 2015 Ford Fusion. The contact stated that there was an abnormal popping sound coming from the vehicle while pulling out of the driveway and driving approximately 10 MPH. The contact stated that the steering wheel seized and locked up. The power steering, Hill Assist, and brake warning lights were illuminated. The contact associated the failure with NHTSA Campaign Number: 19V632000 (Steering). The vehicle was taken to the local dealer, where it was diagnosed that the steering gear had failed and the bolts were corroded. The manufacturer was contacted and confirmed that recalls were VIN-specific, and no assistance was provided. The failure mileage was approximately 177,000.”

“IT FEEL AS IF THERE IS NO POWER STEERING. RAN CODE REPLACED THE Steering wheel angle sensor AND THAT DIDN’T SOLVE THE PROBLEM. I CANNOT STAIR THE STEERING WHEEL GETS LOCKED UP ..”

“I was driving down the road. And front wheels stopped working suddenly. It’s better that I was on streets. Otherwise I could have met with an accident. My mechanic told me that steering rack had gone. I never get any recall for that. I had driven 1400 miles till now.”

“I am reporting a serious and ongoing safety issue involving my 2015 Ford Fusion. The vehicle experiences intermittent power steering failure while driving. The steering assist will suddenly disengage and re-engage without warning, making the vehicle extremely difficult to control. This condition becomes even more dangerous in wet weather, where the vehicle is sometimes nearly undriveable. Additionally, I am now experiencing a popping noise in the steering wheel. This raises concern of a possible mechanical failure consistent with known recalls involving steering wheel bolt defects that could result in the steering wheel detaching. These issues are consistent with known recalls, including: - Power Steering Failure Recall (15V340000) - Steering Wheel Bolt Recall (18V167000 / 18S08) Despite these known safety defects, Ford has refused to repair the issue, stating that the recall has expired. This presents a serious safety hazard, including risk of loss of steering control, crash, injury, or death. I am requesting immediate investigation and enforcement of manufacturer responsibility for this safety-related defect.”

“My steering gear motor attachment bolts have fractured due to severe corrosion, which is the exact defect described in Safety Recall 19S26. This physical failure was confirmed by a Ford dealership technician on 1/11/2024. The technician documented the fractured bolts and recommended a full steering gear replacement. Despite this, Ford is denying the recall repair because this specific VIN was not included on the original mailing list. The vehicle is now undrivable due to a total loss of power steering assist. Before it failed completely, the car was making whining and grinding noises during low-speed turns. This failure occurred in Illinois, which is a high-corrosion 'Salt Belt' state specifically covered by the 19S26 bulletin. By denying this safety repair, Ford is forcing an unsafe vehicle to remain on the road or operate with manual steering, which is a major crash risk. The failure was physically confirmed and documented by a Ford dealer. I want to note that while the previous recall 18S08 for the steering wheel bolt was performed, that was an unrelated interior part and did not prevent this exterior motor bolt failure. I am requesting that the NHTSA…”