2019 Ford Mustang power train problems

“Head gasket blew, and car overheated immediately on the freeway, with no warning signs, and at only 43,000 miles when a failure like this should not occur. Had to find a place to pull over and be towed to avoid more engine damage. Both independent mechanic and Ford dealership has confirmed this. Official diagnosis is "Remove and replace cylinder head assembly and replace head gasket – coolant intrusion cylinder 1, P0316, P0301.” Apparently it's a known issue with this particular engine and has a pending lawsuit.”

“My 2019 Ford Mustang equipped with the 2.3L EcoBoost engine developed a check-engine light, rough startups, engine misfires/rough running, and some engine knocking. The vehicle had approximately 87,453 miles. I took the vehicle to an authorized Ford dealership for diagnosis. The dealer brought the engine to operating temperature, pressurized the cooling system to 21 PSI, removed the ignition coils and spark plugs, and inspected the cylinders with a borescope. The dealer documented coolant intrusion into cylinder #2 due to a failed cylinder head and recommended replacement of the complete long-block engine due to the extent of the damage. The dealer also documented diagnostic trouble codes P0300 and P0316 for misfires, along with P008A and P018C related to low-side fuel pressure. I am concerned that internal coolant intrusion causing misfires, rough operation and engine knocking could result in significant loss of engine power or engine failure while driving, creating a safety hazard, particularly at highway speeds or in traffic. Ford Customer Relations was notified but declined financial assistance because the vehicle is outside the factory warranty and stated…”

“Rebuilt transmissions are bad. Two in the last four weeks have been placed in my 2019 California Special Edition Mustang, and both are bad. They both came from the Ford manufacturer. The transmission locks up at any point while driving at any speed, causing the car to jerk to a standstill, and only while you are driving. We were on 465, and the car automatically stopped in the middle of the highway while other vehicles were flying by and behind me. We were almost hit by several vehicles. This also occurred while the mechanic test drove the car with the second rebuilt transmission placed in my car. No warnings, nothing before this occurred. This is a huge safety hazard and risk for many. The dealership is aware and advised me to contact Ford Motor Company and not to drive my car until something can be done. I have contacted Ford Motor Company, and they have yet to do anything or reach back out to me regarding this safety issue. The car is available for inspection at any time needed since it is still sitting at the dealership with the second rebuilt transmission in it that is no good.”

“My 2019 Ford Mustang Ecoboost Premium Fastback is having an issue with the transmission. When I shift from park to reverse or from reverse to drive, the car makes a clunking noise. There are times when i do a doubletake in my rear view mirror to see if someone has hit me in the back, this happens sometimes when i shift into reverse. Also, I have to stay back at least a car length behind vehicles as the car will sometimes lunges forward which can cause an accident. Will be taking my vehicle into service for this problem.”

“The component that failed on my ecoboost mustang 2019 was a failed design in the motor called the head gasket. The head gaskets broke and started leaking coolant into the engine. The engine has 39,000 miles”

“Since this recall came out I have taken my car to the dealer(Port Orchard Ford, Port Orchard, Wa. 98366) and each time they say they can't do it because it has a super charger. I think it's because they would have to reinstall the super charger program. I've been told that they would be able to reprogram it because they installed it. On the recall notice it doesn't list any exceptions to not doing the recall. XXX XXX REf. Manufacturer Recall Number 22S37 NHTSA Recall Number 22V382 Dated: May 27, 2022”