1998 Ford Taurus service brakes, hydraulic problems

“IN JUNE 2008 I STARTED MY REGULAR YEARLY MAINTENANCE SCHEDULE OF MY 1998 FORD TAURUS WAGON. I HAD MY OIL CHANGE & ROTATED/BALANCED MY TIRES. IN OCTOBER 2008 I HAD TWO TIRES REPLACED (ALL OF MY SERVICE WAS DONE @ A FORD DEALERSHIP IN MY CITY) AND A MULTI-POINT INSPECTION FOR MY VEHICLE INSPECTION. THE MECHANIC ADVISED ME THAT MY CAR NEEDED REAR SHOCKS, AS THE OUTER CASING WAS ROTTED! LEFT INNER TIE ROD WAS LOOSE & FRONT BRAKES WERE WORN. I WENT IN ON OCT 23, 2008 AND HAD ALL OF THE WORK DONE!,$417.45 FOR FRONT BRAKES, RESURFACED FRONT ROTORS; REPLACED FRONT INNER TIE ROD. THEN ON 11/10/08 I WENT IN TO HAVE MY VEHICLE INSPECTED AND WAS ADVISED THAT IT FAILED, THE ROCKER PANELS WERE ROTTED OUT! I MADE AN APPT FOR 11/19/08 TO FIND OUT HOW MUCH IT WOULD COST TO FIX THIS & LEARNED THAT THE ROCKER PANELS WERE NOT AVAILABLE FROM FORD & THAT I NEEDED TO FABRICATE NEW ONES! MY CAR, WHICH HAD 142,555 MILES ON IT, WHICH I THOUGHT TO BE IN PERFECT CONDITION, DID NOT PASS INSPECTION BECAUSE OF SUB-FRAME ROT! THIS VEHICLE HAS ONLY BEEN SERVICED BY FORD DEALERSHIPS, WHO HAD JUST POCKETED $621.45 OF MY MONEY TO PERFORM WORK ON A CAR THAT THEY REFUSED TO INSPECT! IN SEARCHING…”

“WHILE GOING TO WORK BOTH BRAKES LINES ON DRIVERS SIDE WENT BAD AFTER CHECKING WITH MECHANIC. WAS TOLD BOTH LINES WAS ROTTED AWAY. I DO HAVE TO ORDER PARTS FROM FORD. WHICH IS GOING TO CAUSE ME 265.00 TO FIX . MY CAR HAS 49000 MILES. NO REASON WHY BRAKES LINE FAIL NOT A OLD CAR ALWAYS TAKEN CARE OF. *JB”

“DT*: THE CONTACT STATED THE ABS WARNING LIGHT ILLUMINATED INTERMITTENTLY, BUT THERE WERE NO PROBLEMS WITH THE BRAKES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE ABS SENSOR WAS REPLACED, BUT THIS DID NOT REMEDY THE PROBLEM. THE MANUFACTURER AND DEALER HAVE NOT BEEN ALERTED.”

“DT*: THE CONTACT STATED WHILE APPROACHING A STOP AT 15 MPH THE BRAKE PEDAL WAS DEPRESSED. THE VEHICLE DID NOT STOP, CAUSING A REAR END COLLISION WITH ANOTHER VEHICLE. THE BRAKE PEDAL WENT TO THE FLOOR AND WAS SPONGY. SEAT BELTS WERE IN USE AND MINOR INJURIES WERE SUSTAINED BY BOTH THE CONTACT AND PASSENGER. THERE WAS A POLICE REPORT FILED AND THE VEHICLE WAS TOWED. THE INSURANCE INSPECTOR HAS NOT DISCLOSED THE CAUSE OF THE ACCIDENT. THE MANUFACTURER WAS NOT ALERTED.”

“BRAKE LINE CORROSION AND SEPARATION CAUSING FAILURE OF THE BRAKES. RESULTING IN ALSO FRONT SWAY AND LINK BAR DAMAGE. NO BRAKES. FRONT SWAY BARS BREAK WHEN VEHICLE IS TURNED A CERTAIN DEGREE. FRONT MIDDLE OF HOOD ON ALL TAURUS SEEM TO LOSE THE PAINT DO TO ROCK OR DEBRIS BEING ABLE TO BOUNCE ON THE BUMPER AND HIT CENTER. I HAVE SEEN AT LEAST 50 TAURUS'S MISSING PAINT IN THE SAME AREA. SERVICE ENGINE SOON LIGHT REMAINS ON AFTER FOUR TRIPS TO A CERTIFIED FORD DEALER. WATER HOLDING IN ENGINE COMPARTMENT WILL CRACK UNDER EXTREME OUTDOOR TEMPERATURES CAUSING THE CAR TO OVERHEAT.*JB”

“DT: CONSUMER WAS DRIVING THROUGH MCDONALDS WHEN BRAKES FAILED, AND PEDAL WENT TO THE FLOOR. CONSUMER LOOKED OUT OF CAR AND SAW BRAKE FLUID ON GROUND. CONSUMER WALKED TO GARAGE, AND WAS TOLD BRAKE LINE WAS BENT WHICH CAUSED IT TO RUST. BRAKE LINE WAS LOCATED ON DRIVER'S SIDE. CONSUMER WAS TOLD BRAKE LINE WENT FROM FRONT TIRE TO REAR TIRE. WHEN BRAKE WENT OUT THE AIR BAG LIGHT CAME ON. LIGHT WAS YELLOW WITH PICTURE OF AIR BAG DEPLOYED. ALSO, CONSUMER NOTICED THAT DASH IN VEHICLE ON DRIVER'S SIDE WAS SEPARATING. *AK”