2006 GMC Envoy electrical system problems

“Went to drive home at night lights were working then all the sudden went out. Pulled over checked fuses n restarted auto and still no lights, the dash board lights were out as well. Safety of other drivers and my family were affected. Did have to have a friend come and get us. And went to get auto next day n still no lights. When got home checked everything agine and fuses were ok the wireing look all intact. Still no lights. Or dash lights.”

“BOTH DAYTIME RUNNING LIGHTS AND HEADLIGHTS AND HIGH BEAMS CUT OFF WHILE DRIVING. WAS PULLED OVER FOR DEFECTIVE EQUIPMENT. WIRES IN PASSENGER HEADLIGHT MELTED, DIDNT CHECK DRIVERS SIDE. THERE ARE RECALLS ON THE 06 ENVOY HEADLIGHTS, BUT I WAS INFORMED THAT IT DOESNT APPLY TO MY VIN. EVEN THOUGH I AM CAN NO LONGER DRIVE AT NIGHT DUE TO VEHICLE DEFECT”

“I HAVE A 2006 GMC ENVOY DENALI THAT CAUGHT FIRE THIS MORNING, IT WAS AN ELECTRICAL FIRE, CAUSED IN THE HVAC BLOWER CIRCUIT, THE CIRCUIT FUSE DID NOT BLOW, THE CABIN FILLED WITH SMOKE, AND AN OPEN FLAME WAS CREATED. I MANAGED TO PUT THE FIRE OUT, HOWEVER SOMEONE ELSE IN THIS SITUATION MIGHT NOT HAVE EVEN BEEN ABLE TO PULL OFF A BUSY HIGHWAY, LET ALONE EXTINGUISH THE FIRE AS IT WAS UNDER THE DASH BEHIND THE GLOVEBOX. THE SYMPTOMS BEFORE THE FIRE WERE AS FOLLOWS: 1)A FAINT BURNING ELECTRICS SMELL (ELECTRICAL SMOKE IS VERY DISTINCTIVE) 2)BLOWER QUIT RUNNING(WITHIN 30 SECONDS OF SMELL) 3)CABIN FILLED WITH SMOKE (WITHIN 1 MINUTE OF SMELL) TO THE POINT I COULD NOT SEE OUT THE WINDSHIELD 4)OPEN FLAME WAS PRESENT UNDER DASH (WITHIN 2 MINUTES OF SMELL) THE VEHICLE WAS IN MOTION, 50MPH, HEATING SYSTEM WAS RUNNING, OUTSIDE TEMPERATURE 5* FAHRENHEIT. THIS APPEARS TO BE A COMMON FAILURE POINT AS THERE ARE MULTIPLE REPAIR KITS AVAILABLE WITH NEW WIRING CONNECTORS TO REPLACE DAMAGED ONES WHEN REPLACING SPEED RESISTOR THERE WERE NO PREVIOUS ISSUES WITH THE HVAC BLOWER MOTOR SYSTEM”

“TL* THE CONTACT OWNS A 2006 GMC ENVOY. WHILE MAKING A SHARP TURN, THE STEERING WHEEL MADE AN ABNORMAL NOISE AND BECAME DIFFICULT TO TURN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 05V455000 (STEERING). THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE SOFT COPPER HIGH PRESSURE HOSES; HOWEVER, THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO ANOTHER INDEPENDENT MECHANIC AND THE HIGH PRESSURE HOSES WERE REPLACED AGAIN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 100,000.”

“CAR STARTED ON FIRE AFTER TURNING IT ON SEEMED TO COME FROM DASHBOARD,SPREAD TO FRONT SEATS IT WAS PARKED AT THE TIME, FIRE DEPARTMENT STATED IT WAS FROM VENTS ,HEATING MOTOR”

“TL* THE CONTACT OWNS A 2006 GMC ENVOY. THE CONTACT STATED THAT THE MOTOR IN THE DRIVER'S DOOR SHORTED OUT AND THE WINDOW REGULATOR AND MOTOR WERE BURNT. AS A RESULT, THE VEHICLE ALMOST CAUGHT FIRE. SMOKE APPEARED FROM THE DOOR PANEL, WHICH THE CONTACT MANAGED TO PUT OUT. COYLE CHEVROLET BUICK GMC (1801 BROADWAY ST, CLARKSVILLE, IN 47129, (812) 218-1100) DIAGNOSED THAT THE VEHICLE NEEDED A NEW POWER WINDOW SWITCH, FUSE, AND HARNESS. THE REPAIRS WERE COMPLETED BY AN INDEPENDENT MECHANIC. WHEN THE CONTACT DISCOVERED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 13V248000 (ELECTRICAL SYSTEM, VISIBILITY), THE MANUFACTURER WAS CALLED AND ADVISED THAT THE VEHICLE BE TAKEN TO THE DEALER FOR REIMBURSEMENT. THE DEALER DID NOT REIMBURSE THE CONTACT AND PRESENTED THE REPAIR PAPERWORK TO THE MANUFACTURER. THE CONTACT WAS INFORMED THAT REIMBURSEMENT WAS NOT AN OPTION SINCE THE VEHICLE WAS REPAIRED OUTSIDE OF THE DEALER AND MANUFACTURER. THE CONTACT STATED THAT HE DID NOT KNOW OF THE RECALL BECAUSE HE WAS NOT SENT A LETTER. THE FAILURE MILEAGE WAS 148,000.”