Sign inCreate free garage
Problems · by component

1996 GMC Jimmy suspension problems

46 owner complaints to NHTSA about the 1996 GMC Jimmy cite suspension, 11% of all 415 complaints for this model year. NHTSA also lists 2 recalls on this component.

All 1996 Jimmy problems
Complaints
46
11% of all complaints
Crashes
1
Reported by owners
Fires
0
Reported by owners
Injuries
0
Reported by owners
01 —Owner reports

What owners say about the suspension

Verbatim from NHTSA complaints, newest first
“THE FRONT END OF THE VEHICLE VIBRATED WHILE DRIVING. THE DEALER DETERMINED THAT THE FRONT BALLS JOINTS WERE WORN OUT AND HAD TO BE REPLACED. *AK THE DEALER INFORMED THE CONSUMER THERE WAS RECALL ON THE BALL JOINTS, HOWEVER THE CONSUMER'S VEHICLE IDENTIFICATION NUMBER WA NOT INCLUDED. *JB *NM”
Owner complaint to NHTSAFiled Nov 24, 2003SuspensionODI 10044608
“THE CONSUMERS VEHICLE EXPERIENCED THE SAME PROBLEMS AS STATED IN RECALLS 01I018000 LOWER BALL JOINT; RECALL 03V159000 WINDSHIELD WIPER MOTOR, AND TRANSMISSION. RECALL NUMBER UNKNOWN. DEALER WILL NOT REPAIR BECAUSE VIN WAS NOT INCLUDED. *AK THE DEALER REPLACED THE LEFT LOWER BALL JOINT DUE TO A CRACKING NOISE. WHILE DRIVING THROUGH THE SNOW, THE CONSUMER WASN'T ABLE TO USE THE 4WD BECAUSE THE TRANSFER CASE NEEDED TO BE REPLACED. THE WINDSHIELD WIPERS WERE INTERMITTENT, A LOUD CRACKING NOISE HAD COME FROM THE RIGHT SIDE OF THE VEHICLE WHEN TURNING THE STEERING WHEEL. THE SERVICE DEALER STATED THAT THE ONLY PROBLEM WAS THE TRANSMISSION WHICH HAD A LEAK AND THE IGNITION SWITCH. *SCC *JB”
Owner complaint to NHTSAFiled Sep 23, 2003Suspension, Power train, Electrical system, VisibilityODI 10033964
“WHILE DRIVING A CLICKING NOISE COULD BE HEARD, AND VEHICLE WOULD SHAKE. VEHICLE WAS TAKEN TO AN INDEPENDENT AUTO REPAIR SHOP, WHERE MECHANIC DETERMINED THE FRONT UPPER AND LOWER BALL JOINTS HAD TO BE REPLACED. *AK”
Owner complaint to NHTSAFiled Aug 26, 2003SuspensionODI 10037641
“MY 1996 GMC JIMMY HAS HAD BALL JOINT PROBLEMS (UPPER AND LOWER REPLACED AT 40K, 79K), ABS PROBLEMS (RECALLED TO CHANGE S/W, FAILED AT 80K) AND WINDSHIELD WIPER PROBLEMS (INTERMITTENT FAILURES AT 80K). ALL OF THESE PROBLEMS HAVE HAD RECALLS, BUT WHEN I CONTACT GMC THEY TELL ME MY VEHICLE IS NOT INCLUDED (VIN [XXX]). WHAT I DON'T UNDERSTAND IS IF MY CAR IS FAILING WITH THE EXACT PROBLEMS MENTIONED IN THE RECALL NOTICE, THEN THE PROBLEMS SEEM TO BE MORE WIDESPREAD THEN GM IS WILLING TO ADMIT. *NLM *TR”
Owner complaint to NHTSAFiled May 26, 2003SuspensionODI 10019296
“CONSUMER STATE THAT THE VEHICLE WOULD VIBRATE AND MAKE SOME NOISE, CAUSING BY THE LOWER BALL JOINT. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION. TS”
Owner complaint to NHTSAFiled Nov 5, 2002SuspensionODI 8022220
“WHILE HAVING VEHICLE SERVICED TECHNICIAN NOTICED THAT TIRES WERE WEARING OUT DUE TO LOWER BALL JOINTS NEEDED TO BE REPLACED. DEALER WAS CONTACTED, BUT COULDN'T FIND CAUSE. PLEASE PROVIDE FURTHER INFORMATION.*AK”
Owner complaint to NHTSAFiled Sep 9, 2002SuspensionODI 8018148

Showing 6 of 46 reports. Read every report on NHTSA.gov.

Data from NHTSA Complaints API (owner reports, unverified) · synced Nov 11, 2026NHTSA vehicle page
02 —Related recalls

2 recalls on this component

Suspension: upper ball joint

Free remedy

THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1996-1997 4-WHEEL DRIVE CHEVROLET BLAZER, GMC JIMMY, AND OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. SOME OWNERS HAVE HAD TO PAY FOR REPLACEMENT OF THE UPPER BALL JOINTS THAT HAVE SEPARATED. GM IS PROVIDING A SPECIAL POLICY TO THESE OWNERS TO COVER UPPER BALL JOINT REPLACEMENT IF THE CUSTOMER FOLLOWED THE RECOMMENDED MAINTENANCE SCHEDULE FOR THE CHASSIS LUBRICATION AND THE VEHICLE STILL REQUIRED THE REPLACEMENT OF THE UPPER BALL JOINTS DUE TO SEPARATION.

SuspensionReported Dec 4, 2001NHTSA 01I018000

Suspension: upper ball joint

Free remedy

ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.

SuspensionReported Jun 28, 2001NHTSA 01V200000
Data from NHTSA Recalls API · synced Nov 11, 2026

Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.