NHTSA lists 8 safety recalls and 415 owner complaints for the 1996 GMC Jimmy. Most complaints involve service brakes, hydraulic (164) and visibility (65). The EPA rates it 16–18 mpg combined.
ON CERTAIN MINIVANS, PICKUP TRUCKS, AND SPORT UTILITY VEHICLES WITH CERTAIN MODEL-ENGINE COMBINATIONS, THE WINDSHIELD WIPER MOTOR MAY FAIL DUE TO CRACKED SOLDER JOINTS ON THE CONTROLLER CIRCUIT BOARD. THE WINDSHIELD WIPERS COULD WORK INTERMITTENTLY OR NOT AT ALL.
THIS IS NOT A SAFETY RECALL IN ACCORDANCE WITH THE SAFETY ACT. HOWEVER, IT IS DEEMED A SAFETY IMPROVEMENT CAMPAIGN BY THE AGENCY. VEHICLE DESCRIPTION: 1996-1997 4-WHEEL DRIVE CHEVROLET BLAZER, GMC JIMMY, AND OLDSMOBILE BRAVADA SPORT UTILITY VEHICLES. SOME OWNERS HAVE HAD TO PAY FOR REPLACEMENT OF THE UPPER BALL JOINTS THAT HAVE SEPARATED. GM IS PROVIDING A SPECIAL POLICY TO THESE OWNERS TO COVER UPPER BALL JOINT REPLACEMENT IF THE CUSTOMER FOLLOWED THE RECOMMENDED MAINTENANCE SCHEDULE FOR THE CHASSIS LUBRICATION AND THE VEHICLE STILL REQUIRED THE REPLACEMENT OF THE UPPER BALL JOINTS DUE TO SEPARATION.
ON CERTAIN SPORT UTILITY VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF CONNECTICUT, DELAWARE, ILLINOIS, INDIANA, IOWA, MAINE, MARYLAND, MASSACHUSETTS, MICHIGAN, MINNESOTA, MISSOURI, NEW HAMPSHIRE, NEW JERSEY, NEW YORK, OHIO, PENNSYLVANIA, RHODE ISLAND, VERMONT, WEST VIRGINIA, AND WISCONSIN, AND IN THE DISTRICT OF COLUMBIA. FAILURE OF AN UPPER CONTROL ARM BALL JOINT ASSEMBLY COULD OCCUR DUE TO CORROSION.
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
“TL*THE CONTACT OWNS A 1996 GMC JIMMY. WHILE DRIVING AT 30 MPH, THE CONTACT HAD TO ABRUPTLY DEPRESS THE BRAKE PEDAL. HE THEN HEARD A GRINDING SOUND COMING FROM THE TIRES. THE BRAKES WERE CHANGED BY AN INDEPENDENT MECHANIC, BUT THE NOISE PERSISTED. AFTERWARDS, THE MASTER CYLINDER WAS REPAIRED AND THE BRAKES, ROTORS, AND PADS WERE REPLACED. THERE WAS A SLIGHT IMPROVEMENT; HOWEVER, THE NOISE EVENTUALLY RETURNED PERIODICALLY. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 125,000 AND CURRENT MILEAGE WAS 133,000.”
“NHTSA RECALL# 03V 159 000 WINDSHIELD WIPER MOTOR COVER.VEHICLE WAS NOT INCLUDED IN THE RECALL. HOWEVER, THE CONSUMER STATED A RECALL NOTICED WAS RECEIVED FROM THE MANUFACTURER, AND THEY WERE DENYING CONSUMER THE OPPORTUNITY TO HAVE THIS RESOLVED. *AK”
“I WAS DRIVING DOWN I-65 GOING TO WORK, 70 MPH. I LOOKED IN MY REAR VIEW MIRROR AND NOTICE A LARGE AMOUNT OF SMOKE COMING FROM MY 1995, GMC JIMMY, 104000 MILES. I LOOKED AT MY GAUGES AND SAW THAT I HAD NO OIL PRESSURE AND THE CHECK ENGINE LIGHT WAS ON. FORTUNATELY I WAS RIGHT AT AN EXIT. I GOT OFF THE INTERSTATE AND STOP AT A GAS STATION. ALL OF THESE EVENTS HAPPEN IN LESS THAN 5 MINUTES. WHEN I GO OUT I NOTICED ENGINE OIL ON THE OUTSIDE OF MY VEHICLE, DRIVER'S SIDE. I OPEN THE HOOD AND CHECKED THE OIL. NO OIL ON THE DIP STICK. LOOK UNDER THE VEHICLE AND NOTICE A LARGE PUDDLE OF OIL ON THE PARKING LOT. I CALL A WRECKER AND HAD MY TRUCK TOWED TO MY MECHANIC'S SHOP $85. MECHANIC TOLD ME THAT ONE OF THE OIL LINES RUNNING TO THE FILTER AND COOLER HAD FAILED WHERE THE FITTING IS CRIMPED TO THE LINE AND THAT MY ENGINE WAS ALMOST DEPLETED OF OIL. MY MECHANIC REPLACED THE LINE AND FILL THE VEHICLE BACK UP WITH OIL. HE SAID IT TOOK OVER FIVE MINUTES FOR THE VALVES TO QUIT RATTLING. THE REPAIR COST $212. WE DEBATED ON WHETHER TO CHANGE THE OTHER SET OF LINES. WE DECIDED TO WAIT A FEW WEEKS TO SEE IF ANY DAMAGE TO THE VEHICLE SHOWS UP. I AM OUT ALMOST $300 TO DATE, WITH…”
Towing, payload and dimensions aren’t in the EPA or NHTSA data, so we don’t list them.
| Version | City | Hwy | Comb. | Fuel / yr | CO₂ g/mi |
|---|---|---|---|---|---|
| Jimmy 2WD Man 5-spd, 6 cyl, 4.3 L · Rear-Wheel Drive | 16 | 22 | 18 | $3,550 | 494 |
| Jimmy 2WD Auto 4-spd, 6 cyl, 4.3 L · Rear-Wheel Drive | 15 | 20 | 17 | $3,800 | 523 |
| Jimmy 4WD Auto 4-spd, 6 cyl, 4.3 L · 4-Wheel or All-Wheel Drive | 15 | 20 | 17 | $3,800 | 523 |
| Jimmy 4WD Man 5-spd, 6 cyl, 4.3 L · 4-Wheel or All-Wheel Drive | 15 | 20 | 17 | $3,800 | 523 |
| Jimmy AWD Auto 4-spd, 6 cyl, 4.3 L · 4-Wheel or All-Wheel Drive | 15 | 20 | 16 | $4,000 | 555 |
| Item | Miles | Time | Note |
|---|---|---|---|
| Engine oil & filter | 5,000–10,000 mi | 6–12 months | Follow the oil-life monitor if fitted |
| Tire rotation | 5,000–7,500 mi | Every oil change | Check pressure monthly |
| Engine air filter | 15,000–30,000 mi | 1–2 years | Sooner in dusty areas |
| Cabin air filter | 15,000–25,000 mi | 1–2 years | |
| Brake fluid | — | 2–3 years | Absorbs moisture over time |
| Coolant | 60,000–100,000 mi | 5–10 years | Long-life coolants last longer |
| Spark plugs | 60,000–100,000 mi | — | Iridium/platinum plugs at the long end |
| 12V battery | — | 3–5 years | Heat shortens battery life |
8 safety recalls as of Oct 28, 2026, according to NHTSA. Recall repairs are free at a dealer. Check your VIN to see whether your car is included and whether the repair was done.
Owners filed 415 complaints with NHTSA. The most-cited components are service brakes, hydraulic (164), visibility (65), engine and engine cooling (48). Complaints are unverified owner reports and aren't adjusted for how many cars were sold.
The EPA rates the 1996 GMC Jimmy at 16–18 mpg combined, depending on engine and drivetrain (5 versions rated).