2021 GMC Sierra engine and engine cooling problems

“The contact owns at 2021 GMC Sierra 1500. The contact stated that while driving 60 MPH, the engine was overheating. The message "Reduce Engine Power" was displayed. The contact shifted to neutral to reach the dealer. The contact associated the failure with Special Coverage: N252508341; however, the VIN was not included. The dealer diagnosed the vehicle with coolant control valve failure, and the vehicle was repaired. The manufacturer was made aware of the failure and stated that the cost of the repair was not covered under the special coverage program. The failure mileage was approximately 94,328.”

“The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving at 60 MPH, the vehicle began to shake uncontrollably. A knocking sound was heard from the engine, and the vehicle entered limp mode. No warning lights illuminated. The contact was able to coast the vehicle to the residence. The vehicle was later towed to the dealer, where it was diagnosed that the engine failed and needed to be replaced. The contact associated the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling). The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the VIN was not included in the recall, and the contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was 81,000.”

“The contact owns a 2021 GMC Sierra 1500. The contact stated that the vehicle was experiencing excessive oil consumption. The low oil level was observed, and the oil warning light illuminated. The vehicle was previously serviced at the dealer, where it was discovered that the oil was 3 quarts low at approximately 56,653 miles. The vehicle was returned to the dealer, where an oil consumption test was performed. After driving 3,000 miles, it was observed that the oil level was 2 quarts low on July 16, 2024. The dealer confirmed there was no recall coverage, and the vehicle was not repaired. The contact associated the failure with NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); however, the dealer and manufacturer confirmed the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 59,075.”

“The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving approximately 70 MPH, the vehicle suddenly lost motive power, decelerated, and failed to properly accelerate while depressing the accelerator pedal. The check engine warning light was illuminated. After exiting the freeway, the vehicle stalled. The vehicle was towed to the residence and then later towed to the dealer for assistance. The contact was informed that there were metal shavings inside the engine oil. The contact was informed that the engine needed to be replaced. The vehicle was not yet repaired. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The manufacturer was not yet contacted. The failure mileage was 149,000.”

“The contact owns a 2021 GMC Sierra 1500. The contact stated that while driving 35 MPH, the engine was making an abnormal sound, and the vehicle failed to accelerate. The engine was popping and making cranking sounds, with several unknown warning lights illuminated. The vehicle was driven back to the residence with the issues. The contact referenced NHTSA Campaign Number: 25V274000 (Engine and Engine Cooling); as a possible cause for the failure; however, the VIN was not included in the recall. The vehicle was taken to a dealer where it was determined that there was metal fragments found in the oil filter, and recommended that the engine be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 50,000.”

“The contact owns a 2021 GMC Sierra. The contact stated that while driving at approximately 40-45, the engine warning light illuminated. There was an abnormal sound coming from the fan. The vehicle was taken to the local dealer, where it was diagnosed and determined that the coolant flow valve needed to be replaced. The vehicle was not included in a special coverage program. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 50,000.”