2025 Honda CR-V engine problems

“My 2025 Honda CR-V Hybrid (VIN: [XXX]) has an open Product Update campaign for the PGM-FI Software Update (coolant pump/overheating risk). An authorized Honda dealership (Herb Chambers) refused to perform this software update, instructing me to return to the selling dealer. The vehicle has experienced repeated engine overheating warnings and significant coolant loss. This refusal to perform a safety campaign leaves the vehicle at risk of engine damage and potential safety hazard.”

“While driving on a highway, the vehicle suddenly lost power and could no longer maintain highway speed. It entered a reduced power mode, flashed multiple errors, and was pulled over to the shoulder and stopped. My pregnant wife, who was in the car by herself, was then stuck in a hot car on a dangerous elevated spot on a highway with high-speed traffic close by and on a limited shoulder. It had to be towed to a dealership. The dealership diagnosed a misfire in cylinder 2. The technician removed the spark plugs and found them fouled with oil, primarily one plug. Using a borescope, the technician inspected all cylinders and found a crack across the piston in cylinder 2. A head gasket failure was initially suspected but was ruled out. The oil was drained and inspected, and no metal debris was found in the drain pan. The failure was confirmed by the dealership, and a warranty claim was submitted to and approved by the manufacturer. The approved repair covers replacement of the piston, rings, rod bearing, and head gasket for cylinder 2 only, rather than the short block originally recommended by the technician. The dealership stated that root cause cannot be…”

“I am reporting a severe factory design defect regarding water intrusion into the EVAP emissions system on my 2025 Honda CR-V Hybrid (VIN: [XXX]) After driving home in a normal rainstorm, the vehicle threw diagnostic trouble code P24C0 (EVAP system leak detection pump switching valve stuck ON). The authorized Honda dealership diagnosed the issue as "water intrusion" and charged me an out-of-pocket fee. The dealer's official service invoice explicitly states that the water intrusion occurred from "driving through a puddle." Driving through a standard road puddle or driving in a rainstorm constitutes standard, expected, and necessary vehicle operation. The EVAP canister is a federally mandated emissions component that must legally remain sealed against atmospheric leaks. Because normal road moisture can bypass factory shielding and flood or damage this critical component, it represents a clear engineering and manufacturing defect in sealing and part placement, rather than owner negligence. Honda is systematically denying factory warranty coverage to owners for this specific issue by labeling normal road rain as "outside environmental damage." This leaves drivers…”

“The contact owns a 2025 Honda CR-V. The contact stated that while driving on a toll road, there was an abnormally loud sound coming from the engine and vehicle started losing automotive power and the vehicle decelerated unintendedly. The vehicle was later towed to a local dealer who inspected the engine and discovered metal shavings inside the engine oil. The cause of the engine failure was not yet determined, and the vehicle was not yet repaired. The manufacturer was notified of the failure. No further information was available. The failure mileage was 980.”

“The contact was driving , experienced tire pressure and check engine light illuminated. white Smoke was seen underneath the vehicle and then it turned black. Then fire was seen coming from underneath the vehicle. The contact pulled over to the shoulder of the vehicle , and smoke and fire was seen underneath the vehicle. The fire department was called and extinguished the fire. The vehicle was consumed by the fire. The vehicle was towed to a tow and recovery lot. No injuries were sustained. The dealer was notified of the failure. the manufacturer was not notified of the failure. The approximate failure mileage was”

“The contact's son owned a 2025 Honda CR-V. The contact stated that while her son was driving on the parkway at approximately 40 MPH, a loud, booming sound emit from the vehicle. After the booming sound emitting from the vehicle, several warning lights appeared on the instrument panel as the vehicle caught fire. Due to the sudden failure, the vehicle caught fire and the authorities were called to the scene. Once the fire department arrived at the scene the fire was extinguished. No injuries or property damage were reported. A police and fire report was filed. The vehicle was towed to an independent body shop where it was deemed a total loss as the vehicle was incinerated as a result of the fire. The dealer and the manufacturer were notified of the failure and the contact was given a case number by the manufacturer. The vehicle was destroyed as a result of the failure. The failure mileage was approximately 10,850”