2023 Hyundai Santa Fe Hybrid engine problems

“I am filing this complaint regarding an EGR valve failure in my 2023 Hyundai Santa Fe Hybrid, VIN [XXX]. My vehicle experienced an EGR valve malfunction at approximately 93,500 miles. The Hyundai dealership diagnosed the EGR valve with an internal fault and replaced it. I had to pay approximately $1,700 out of pocket because Hyundai declined warranty assistance based on the vehicle's mileage. My vehicle is also associated with Hyundai Service Campaign 9C7, which addresses improvements to the Engine Control Module (ECM) software related to EGR system operation. I understand that Campaign 9C7 involves a software update rather than automatic EGR valve replacement. However, Hyundai's Technical Service Bulletin 26-01-081H identifies excessive condensation accumulation within the EGR system and potential EGR valve corrosion as known concerns. I am concerned that my EGR valve failure may be related to the same underlying condition identified by Hyundai. Although the ECM software update had previously been completed, the mechanical EGR valve subsequently failed. I contacted Hyundai Motor America requesting reimbursement for the repair expenses. Hyundai denied my…”

“The vehicle came to a complete stop filling cabin with smoke and wouldnt start in a bend on road blocking entrance ramp. Its available for inspection but at dealership. My safety was put at risk for collision as well as health with cabin filling with smoke. The dealer still has vehicle going on 3rd day without answers. The vehicle had warning come on for hybrid system failure appearing shortly before dying completely with smoke filling cabin.”

“Own a 2023 Hyundai Santa Fe Hybrid and have experienced the following issues over the past year and a half. Beginning after maybe 40,000 miles we pulled out onto a roadway and the engine immediately lost power and started flashing a glaring red warning that the hybrid system was failing and to pull over. We luckily were able to and turned the car off and waited. I tried to turn it on and it came back to life as if there was never an issue? We drove off. it left no warning code or did not update my Bluelink App. I took it to the dealership and they could not find any issues. Fast forward another 5 or 6 months and it happens again. Take it to the dealer and they keep it a week to go over it but still nothing. Within a week of getting it back it happens again and this time I am videoing it happening to me. Back to the dealer and provide the video because again the car did not log the event nor did it update my app. They hold it again for a week and try different things. They still cannot figure it out and I get it back.... it happens again.... This time the dealership was able to come up with an answer and that the oil level was too high. I got the car back and it…”

“One two separate occasions while driving the car has lost the ability to accelerate. There is no acceleration power even when completely flooring the gas pedal. The dash displays a red circle warming that states "Check Hybrid system. Stop Safely". I have had to coast to the side of the road and then the car shuts off. It has taken several minutes before it can start again, and then displays a warning "Park with engine On to charge battery" before being able to shift the car into drive. I immediately took the vehicle to the dealership at which I had purchased the car. They have run a diagnostic on it and did not find any error codes stored in the computer. I picked up the vehicle from them and immediately upon pulling out of their lot it happened again. After losing power, coasting to the side of the road, and waiting for the engine to be able to restart I took it immediately back to the dealership. They have had my car for 5 weeks and cannot diagnose the problem or offer any recommendations for repairs.”

“On September 4, 2025 as I pulled on to Interstate I-70 my car suddenly lost power. Gas engine died. Loud attention sound started. Instrument cluster started flashing red with message "EV system failure, stop immediately" EV battery showed full depletion although a moment before it showed about 75% power. There was only enough propulsion to keep moving slowly. Since this was a construction zone the shoulder was blocked off and roadway was reduced to only one lane. I had no where to go. A large truck narrowly avoided rear ending me. I was scared and felt helpless. Eventually I was able to pull off and shut off the car. It was able to be re-started immediately with no warning indicators and EV battery power restored. This loss of power has happened 6 times before during the time I have owned the car. Last time was in March 2025. Each previous time it happened I was traveling at about 35 miles per hour and while annoying I did not fear for my life. On March 6, 2025 I had the dealer, McCarthy Hyundai, check out this problem. There were no detectable problems or problem codes. I was told that it might have been caused by the oil dip stick not being fully seated. It…”

“I am reporting a serious and recurring safety defect with my 2023 Hyundai Santa Fe Hybrid, purchased new in January 2024. The vehicle has suffered from over 30–40 sudden hybrid system failures, including loss of acceleration, “Stop Vehicle” warnings, and check engine lights. These incidents happen without warning, including while driving at legal speeds (40–70 mph), on residential streets and highways. Most recently, the car failed twice in two days, while my teenage son was driving within all road laws, including once with a friend in the car. The vehicle simply stopped accelerating in the middle of traffic, endangering them and everyone around them. These failures have happened at legal speeds ranging from 40–70 mph, on both residential roads and highways. There is no advance warning, just abrupt loss of power and sudden warning messages. We’ve taken the vehicle to the South Charlotte Hyundai dealership multiple times. Each time, they either reset the check engine light or replaced indicators: but never addressed the root hybrid system failure. We filed a lemon law case, and Hyundai responded with only a $2,000 offer including legal fees, requiring us to keep…”