2017 Hyundai Santa Fe fuel/propulsion system problems

“The engine light came on. Upon driving it on the highway it would lost acceleration but was able to drive under 50 miles per hour about 5 miles. When opened the hood there was fluid splattered on the engine. There is a hole in the upper left quadrant beneath the engine cover.”

“Hyundai performed recall #9C2, on 7/2/26. Since that time, the engine has a full time miss. When it is cold, it will hesitate, kick and buck. Hyundai is aware of this. Their solution is to warm the car for 3 to 5 minuets before moving. What happens if there is an emergency and you can't wait? Possible accident with injuries trying to pull into, or cross traffic! I have filed a case with Hyundai, and they just update that they are aware and working on a solution with no expected date for the software fix. This is a serious problem, and they need to fix SOON! Also, when an engine runs like this, over a period of time it will destroy the catalytic converter. Who's going to pay for that??”

“Directly after the dealer, Johnson Hyundai of Apex, completed Service Campaign 9C2 on 4/28/26, my vehicle began sticking, surging, and harshly changing gears. I have followed up with the dealer multiple times. They said they are not getting back any diagnostic error codes (outside mechanic shop also confirmed they're also not seeing error codes), but went ahead and recalibrated the ECM. They told me to drive for 200 miles and the issue should be resolved. I have now driven 1,500 miles and the issue persists. I'm now seeing Hyundai put out a 'Driveability Communication" about this issue, but there is no proposed fix/recall. This issue did not exist before this service campaign was performed by the dealership.”

“Complete unmitigated loss of acceleration and power while traveling at highway speeds, creating an immediate life-threatening road hazard. Following a warranty engine replacement and mandatory dealer software flash at Clay Cooley Hyundai (Sherman, TX), the vehicle began experiencing powertrain communication issues. While operating the vehicle at 65 MPH on the highway, the vehicle completely failed to accelerate and lost propulsion power, nearly resulting in a catastrophic rear-end collision with an oncoming 18-wheeler semi-truck. Dealership diagnostics claim "no trouble codes present," but live data telemetry confirms the High-Pressure Fuel Pump (HPFP) is actively commanding and delivering a dangerous 1,600 PSI to the fuel rail at hot idle. This abnormal fuel delivery is paired with a severe powertrain stutter in 3rd gear. Service personnel at multiple locations confirm a widespread, high volume of transmission failures and severe drivability issues specifically tied to this recent Hyundai software update. Corporate has denied repair coverage. The vehicle remains an active highway safety hazard and is completely undrivable.”

“I own a 2017 Hyundai Santa Fe Sport 2.4L (VIN: [XXX]). On XXX, my vehicle received Campaign 9C2 (ECU software update for Theta II emissions improvement). Shortly after this update, I began experiencing a drivability issue that did not exist beforehand. Description of the issue: The problem occurs only after the vehicle has been sitting long enough for the engine to become completely cold, typically overnight. During approximately the first 1/4 mile of driving, the vehicle intermittently jumps, surges, or lurches while accelerating normally. Once the engine warms up, the symptom completely disappears and the vehicle drives normally for the remainder of the trip. There are no warning lights, no check engine light, and no diagnostic messages. The Hyundai dealer has had the vehicle for nearly a week but has been unable to reproduce the concern. Because the issue only occurs during the initial cold start and first portion of the drive, I am concerned that it may not have been tested under the same conditions in which I consistently experience the problem. I am not claiming that Campaign 9C2 caused the issue, but the timing is notable because the symptom began only…”

“Hi, my name is [XXX], i bought used Hyndai Santafe sport 2017 from dealership in 2020. It had around 47,000 Miles on it, intitially it was running fine but after driving 2 years i discovered that engine is burning oil and after the oil change right after 1000 miles i had to add a quart of oil and it was like every two weeks. I had many srevices from dealership and other auto mechanic stores but it didn't improved. I had no choice but to keep driving the card on XXX th the engine crashed with out any sign on dashboard. There was slight noise and it increase by the way car was parked on the side road from Highway. The car was towed to my local mechanic and confirmed that engine is crashed. After i had to towed to dealership and i am still waiting for their response. Now we have put 43,000 miles in 6 years (91,000) total mileage. I had bought the waranty from dealership by $ 2500 which expired in 2025 Currently no warranty. My question here is that the car is still under 100,000 and engine failed. What if the dealership refuse to replace the engine. What are my leagal rights. Thanks [XXX] [XXX] [XXX]”