2019 Hyundai Santa Fe problems

“On 03/26/2026, my 2019 Hyundai Santa Fe received Hyundai Service Campaign 9C2 (TSB 26-01-013H-1), which included an Engine Control Module (ECM) software update for Theta II emissions improvement. The vehicle did not have the following drivability problem before this software update. Immediately after the 9C2 update, the vehicle began jerking/bucking slightly at low speeds, most noticeably around 10-20 mph when coasting with no accelerator input or when applying very light throttle. Acceleration response also feels slower than before the update, with noticeable hesitation when the accelerator is pressed. The problem is most noticeable during the beginning of a drive when the vehicle is cold. After driving for some time and the vehicle warms up, the symptoms improve, although the change in drivability remains noticeable compared with operation before the update. There have been no warning lights or warning messages associated with the problem. The issue began immediately following the ECM software update. The vehicle has not yet been returned to the dealer for diagnosis or confirmation and is available for inspection. I am concerned about the safety implications…”

“Driving at highway speed, vehicle stuttered/lurched. The check AWD, engine light, tire pressure warning lights came on. Check by mechanic resulted in error code P0741 (Torque Converter Clutch Circuit Performance or Stuck Off). Search of error code P0741 indicates that there is a Technical Service Bulletin TSB-23-AT-005H regarding this KNOWN problem. A stutter or lurch of the vehicle can cause the driver to over react, stop or swerve suddenly in traffic potentially causing an accident not to mention possible being struck on the side of the road while waiting for a tow/service truck. Vehicle/components have not been checked by manufacturer--only diagnostic code by Mechanic. Warning lights after incident included the AWD system, Check Engine Light, and Tire Pressure sensor light. Vehicle is being towed to a Hyundai Dealership as Mechanic advised it is not safe to drive.”

“On August 14 2026, I drove my 2019 Hyundai Santa Fe approximately one mile from my residence to work at approximately 5:00 AM. The vehicle was operating normally and I experienced no warning lights, unusual noises, odors, smoke, or other indications of a problem. I parked the vehicle in an outdoor parking lot and the vehicle remained parked and turned off for approximately four hours. At approximately 9am, I was notified that my vehicle was smoking. A person who was walking past the vehicle observed the smoke, obtained a fire extinguisher, and extinguished the fire. The fire department subsequently responded, disconnected the vehicle battery, and opened the rear of the vehicle to ventilate it. The fire and resulting heat damage were concentrated on the driver's side rear of the vehicle, directly behind the driver's-side rear tire and in the area of the rear bumper. The plastic at the base of the bumper melted, and melted bumper material was observed dripping onto the ground. The responding fire marshal inspected the vehicle and indicated that the electrical box located in this area may be associated with the origin of the fire. Wiring from this area runs to a…”

“The door was completely shut - I was driving on the highway - no alarm on the instrument panel, fully stage 2 latched ( even if it is just stage 1 latched - the instrument panel gives an alarm - there was no alarms about door not fully closed) everything was normal. 15 minutes into the drive - I was exiting the highway, making a right hand turn - the door suddenly popped open, alarm went off on the instrument panel - thankfully did not swing open, I was able to hold onto the door. I shut the door again - drove for 200 Miles - no issue again. This was the first ever time I saw this issue at 90K miles”

“Overly excessive oil consumption 2 Quarts every 3 or 4 days.no leaks. Engine gets so hot I don't have to turn on heater In winter. On going issue since 100,000 miles. EBS light stays on electronic parking brake switch does not work. Parking brake will randomly engage after vehicle is turned off. Dealership cannot duplicate issue. If cruse control is turned on the vehicles warning lights all of them will suddenly illuminate and the vehicle shuts off. alternator and battery replaced. Have not used cruse control since. Airbags never inflated in a front end crash at 45mph Most recently I started experiencing I intermittent trouble staring the car. Then one day it didn't start at all and smoke was coming from under the hood. Towed to mechanic , starter burnt up 155,000. $ 900 to replace then a couple days later I lost power on the freeway and the car started jerking and vibrating. Stopped Vehicle cut off and would not start. After 1hr I started and limped home. Vibration under 2000 RPMs and when stopped. Knocking noise under hood. Brand new spark plugs. Mechanic stated Cylinder 3;missfire was identified as a hole in a valve due to weak material now I have to replace…”

“The vehicle experienced a sudden, intermittent engine stall while driving, specifically when slowing down or coasting to a stop in live traffic. When the engine dies, the vehicle immediately loses engine power, power steering, and power braking assist, creating an extreme safety hazard. After stalling, the vehicle refuses to restart for several minutes. An authorized Hyundai dealership previously replaced the high-pressure fuel pump under warranty to address this issue, but the dangerous stalling has persisted over the last 2,000 miles. The vehicle continues to randomly shut off without throwing a permanent check engine light or diagnostic trouble code, and the manufacturer has failed to correct this critical safety defect.”