2023 Hyundai Santa Fe power train problems

“My 2023 Hyundai Santa Fe Calligraphy has experienced transmission problems since it was new and currently has approximately 20,000 miles. I brought it to the dealership approximately three to four times for these concerns, but I was told they could not find a problem or any diagnostic codes. Recently, while driving on the highway, the vehicle lost power and would not accelerate even with the accelerator pedal pressed all the way down. I had to pull over to the side of the highway. Without turning off the engine, I shifted into Park and then back into Drive. The vehicle began moving again, but the transmission continued slipping. On [XXX] I brought the vehicle to Key Hyundai of Manchester for scheduled maintenance and again reported the recurring transmission problems. The dealership requested a diagnostic fee of more than $200, which I declined because I had repeatedly reported this problem since the vehicle was new. They completed the scheduled maintenance without performing the requested transmission diagnosis. After leaving the dealership that same day, the vehicle repeatedly malfunctioned while I was driving, and the check engine light came on. I returned…”

“I own a 2023 Hyundai Santa Fe Calligraphy AWD equipped with the 2.5L turbo engine and 8-speed wet dual-clutch transmission. At approximately 39,900 miles, the check-engine light illuminated. Hyundai Bluelink diagnostics reported powertrain/TCU diagnostic trouble code P1C2D03, identified as a high-pressure electric oil pump motor position sensor fault. I am concerned because this same diagnostic trouble code and high-pressure electric oil pump/transmission issue was associated with Hyundai Safety Recall 236 (NHTSA Recall 22V746) involving certain earlier Santa Fe model years. Hyundai's recall documentation described the possibility of the transmission high-pressure electric oil pump malfunctioning and causing loss of motive power while driving. My vehicle is a 2023 model and therefore was not included in that earlier recall, but Hyundai has subsequently issued technical service information covering 2021–2023 Santa Fe vehicles equipped with the 2.5T engine and 8-speed wet DCT, including vehicles displaying DTC P1C2D03. The current Hyundai service procedure indicates that affected vehicles may require transmission replacement. I have stopped driving the vehicle…”

“Subject: Formal Dispute: Warranty Breach and Failure to Repair – 2023 Hyundai Santa Fe Timeline & Facts:11/2/25 (~52,000 miles): I officially reported an intermittent loss of power and severe engine revving (up to 7,000 RPM). This created a severe safety hazard when merging and accelerating from an idle stop.3/28/26 (Under 60k miles): After months of diagnostic delays, Hyundai confirmed the Dual-Clutch Transmission (DCT) needed replacement under the 60,000-mile warranty. A Hyundai Case Manager tracked the issue.Service Delay: Hyundai delayed repairs due to a lack of loaner vehicles, which were grounded for recall updates. Commuting pushed my mileage to 60,218. The Case Manager assured me coverage was locked in because the defect was documented before 60,000 miles.4/8/26: Due to corporate protocol, they ordered a valve body installation instead of a new transmission.8/11/26: The valve body failed. Hyundai delaership resubmitted the transmission replacement request. Corporate denied 100% coverage because the odometer was now over 60,000 miles (60,218). They are offering only 80%, leaving me with a $1,000 plus out-of-pocket expense.Legal & Contractual…”

“This complaint concerns a serious, unresolved powertrain/propulsion safety defect in my 2023 Hyundai Santa Fe. While traveling approximately 70 mph, the vehicle suddenly lost propulsion and would not accelerate normally while surrounded by highway traffic.MOST IMPORTANTLY, THERE WAS NO WARNING OR ADVANCE INDICATION. No warning lights, messages, or symptoms appeared before the loss of propulsion. I had no opportunity to anticipate the failure or prepare to safely exit traffic. This placed me and other motorists at immediate risk of a serious or potentially fatal collision.A Hyundai dealership inspected the vehicle and documented DTC P284001, Shift Fork D Position Fault. Despite this documented fault, the underlying safety issue remains unresolved. Hyundai has not identified a permanent correction or established that the vehicle is safe to operate.There has not been another incident because I will not risk another sudden loss of propulsion by driving the vehicle. The absence of another failure does NOT mean the problem is resolved. The vehicle remains available for inspection.I have repeatedly sought assistance from Hyundai and the dealership without a meaningful…”

“COMPONENT/SYSTEM: The powertrain launch control system — the Transmission Control Unit (TCU) and 8-speed wet dual-clutch transmission paired with the 2.5T engine — fails to deliver engine power in response to full accelerator input from a stop. The engine does not rev and the vehicle does not move for approximately 1–2 seconds despite the accelerator pedal being fully depressed, then power engages abruptly and violently. The vehicle is available for inspection upon request. SAFETY RISK: The failure occurs when launching from a stop into intersections and cross-traffic. In the most recent incident, I was turning left across the roadway from a stop with an oncoming vehicle approaching. I applied full accelerator and the vehicle did not respond at all for approximately 2 seconds — no engine response, no movement — leaving me stationary in the oncoming vehicle’s path. Power then engaged violently and without warning, causing the vehicle to lurch across the road. I was nearly struck. Similar events have occurred multiple times throughout my ownership; this was the closest to a collision. DEALER CONFIRMATION: Not yet inspected by a dealer. A dealer service…”

“Vehicle stalled while driving — unsafe loss of power. While driving at normal speed, the vehicle suddenly shut off without warning and the electrical system malfunctioned. I had to pull over and restart car. This created a dangerous situation and could have caused a collision. Prior to this incidenct, the vehicle had intermittent electrical issues during startup (flickering electronics). This is the first time the car has experienced during driving, and is now at the Hyundai dealership. The car has been reported as unsafe to drive. This appears similar to other Hyundai stalling/power loss issues and may indicate a developing safety defect. Requesting investigation.”