2017 Hyundai Sonata Hybrid engine problems

“My 2017 Hyundai Sonata Hybrid suffered a sudden and dangerous engine failure matching the exact conditions of NHTSA Safety Recall 209 (Hyundai Campaign 209) for premature connecting rod bearing wear. The vehicle entered Limp Mode due to diagnostic trouble code P1326. The mandatory Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the failure. The vehicle is currently located at Hyundai of [XXX], where dealership technicians confirmed that the engine is completely failed and requires replacement. However, the dealership and manufacturer are actively refusing to perform the mandatory safety recall remedy, instructing me to pick up the un-repaired, hazardous vehicle. They are citing the vehicle's salvage title as the sole reason for denial. Under federal NHTSA regulations, a manufacturer cannot deny a safety recall remedy based on a salvage or branded title status unless the vehicle cannot be physically or safely repaired. This engine defect poses a documented fire and stalling hazard. I am filing this immediate complaint because Hyundai is violating federal recall mandates by attempting to discharge a vehicle…”

“The Hybrid Electric Vehicle (HEV) system in my 2017 Hyundai Sonata Hybrid Limited malfunctioned. On three separate occasions, the HEV warning light illuminated while I was driving on the highway, followed by a sudden loss of power. The vehicle stalled and stopped running, leaving it inoperable. The incidents occurred in approximately August 2022, November 2023, and February 2026. The vehicle is available for inspection upon request. Each incident occurred while driving on a highway. The vehicle suddenly lost power and stalled in moving traffic, creating a significant safety hazard. I was forced to attempt to move the vehicle out of active traffic lanes while other vehicles were traveling at highway speeds. The unexpected loss of propulsion increased the risk of a crash, serious injury, or death to myself, my passengers, and other motorists. The vehicle was taken to a Hyundai dealership after each incident. However, the dealership did not provide an explanation for the HEV warning light, loss of power, or stalling condition. To my knowledge, no permanent repair was identified, and the problem recurred on multiple occasions. The vehicle was inspected by a Hyundai…”

“2/25/2026 vehicle was put in service for a safety warranty recall. 2/26/2026 Hyundai approved the replacement of the engine, but there were costs involved that I was responsible for (approx. $800). 3/9/2026 I was informed by Hyundai the vehicle was complete, and would now last "for another 200,000 miles". I picked up the vehicle and only drove 5+ miles from the dealership when the vehicle’s motor completely shut down, putting me in a VERY UNSAFE driving condition, almost causing a serious accident. Vehicle was returned to Hyundai the same day and I was informed they were still figuring out the failure and to be patient. 3/11/2026 Hyundai informed the vehicle would now need a new catalytic converter and O2 sensor, and that it would all be covered under warranty. On 3/12/2026 Hyundai informed me that they would not fully cover the cost of the new parts and I ended up paying another $1300. 3/19/2026 Hyundai notified me that the vehicle service was complete, and the vehicle was ready for pick-up. I picked up the vehicle that day and again only drove 5+ miles when the vehicle repeated the same failure with the motor completely shutting down and again putting me in a…”

“The engine shut off on the highway on two different days. Vehicle was going between 65 and 70 mph. The vehicle engine shut down and all the warning lights came on. Every one. The vehicle still moved but nothing inside worked, it ran on battery mode for the 17 miles to the dealership with a maximum speed of 60 mph. The risk was the immediate unresponsiveness of the vehicle and the sudden and immediate reduction in speed and power. It presented itself twice in about 2,000 miles. The dealership charged a 491$ diagnostic and found all the warnings and reset it, not reason for it happening and sent me on my way. Then it happened again. Brought back to the dealership and they tried to say they did another diagnostic and called the tech helpline. It took hours and they still don’t have a definitive answer, wanted to try almost 2k in repairs to see if it would fix the issue without any guarantees it would. Warning lights, all of them came on, cruise control, abs, engine light blinking, steering, literally everything and messages started running through the information center.”

“FAIL/MALFUNCTION 3/18/25: Internal engine failure diagnosed by local Avondale, AZ Hyundai dealership service - rod bearing failure suspected. Vehicle currently undergoing Bearing Clearance Test to affirm this or any connecting rod issues, with possible need for total engine replacement. When googling "Hyundai Sonata hybrid 2017 internal engine failure," masses of reports generate from consumers with this model, complaining of same defect, as do numerous recalls for such defects that have been mandated for the model with range of years including 2017.Yet when searching with my VIN, it says no recalls have been mandated, in spite of the undeniable, widespread identical defect. Available for inspection. SAFETY RISK: Driving on the freeway in city traffic at 70-75mph, the engine completely stopped and all dash lights lit up at once. Vehicle had to be coasted to shoulder to wait for roadside assistance. Extremely hazardous to us in vehicle and to all around us with sudden, dramatic speed change in moving, constant freeway traffic. First time: Our usual mechanics at Pep Boys did diagnostic but found nothing, the vehicle drove normally for them, yet they did our…”

“The contact's son owns a 2017 Hyundai Sonata Hybrid. The contact stated that while her son was driving at an undisclosed speed, he smelled a burning odor on the interior of the vehicle, after which he heard an abnormal sound coming from the engine compartment. The check engine warning light was illuminated. The vehicle was taken to the dealer to be diagnosed; however, the contact was not aware of the diagnostic report. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 21V727000 (Engine); the VIN was included, and parts were available. The contact also stated that the vehicle had a Salvage Title. The manufacturer was not notified of the failure. The failure mileage was 66,000.”