2017 Hyundai Sonata Hybrid problems

“My 2017 Hyundai Sonata Hybrid suffered a sudden and dangerous engine failure matching the exact conditions of NHTSA Safety Recall 209 (Hyundai Campaign 209) for premature connecting rod bearing wear. The vehicle entered Limp Mode due to diagnostic trouble code P1326. The mandatory Knock Sensor Detection System (KSDS) software update was successfully completed on this vehicle prior to the failure. The vehicle is currently located at Hyundai of [XXX], where dealership technicians confirmed that the engine is completely failed and requires replacement. However, the dealership and manufacturer are actively refusing to perform the mandatory safety recall remedy, instructing me to pick up the un-repaired, hazardous vehicle. They are citing the vehicle's salvage title as the sole reason for denial. Under federal NHTSA regulations, a manufacturer cannot deny a safety recall remedy based on a salvage or branded title status unless the vehicle cannot be physically or safely repaired. This engine defect poses a documented fire and stalling hazard. I am filing this immediate complaint because Hyundai is violating federal recall mandates by attempting to discharge a vehicle…”

“While traveling 40 mph, car flashes a warning, "Check Hybrid System", and then the car shuts off. No power steering and brakes are difficult. The warning is only 3-5 seconds before everything shuts down. This is definitely a hazard to myself and others. If in traffic at higher speeds, there would certainly be an accident with devastating results.”

“What component or system failed or malfunctioned, and is it available for inspection upon request? Vehicle stopped accelerating and flashing check engine light went on. Vehicle reported "Check Hybrid System." Dealer believes it was loose pins in a HCULDC connector that may have caused loss of communication. How was your safety or the safety of others put at risk? Lost acceleration on a highway and was nearly hit trying to get off of the road. Has the problem been reproduced or confirmed by a dealer or independent service center? Piazza Hyundai of Pottstown, PA reproduced the issue. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Dealer secured loose pins. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No.”

“Driving the vehicle, I was turning right on exit , the steering wheels turn extremely hard. It turn so hard have to pull over on side of the road. Steering light and traction turn on. Cycle the key and vehicle reset light nothing happen. Vehicle do not give fault code after key was cycle.”

“Literally for years I have been taking my car in to Rick Case Hyundai with the complaint of smelling gas even when the car was parked for long periods. Each time they said they fixed with different items. Gas cap, a part on the catalytic converter, etc. The problem never resolved but I noticed it only happened when the tank was more than half full. I got a video of gas dripping out underneath and took the car to Rick Case and gave them the video. My car has been there ten days because they first tried to say it was a seal on the fuel pump. This time I said that seems unlikely cause that only happens when tank is full and persists even after car is parked many hours. Now they report they found a pinhole leak in the gas tank. I will upload the video if this form allows. This does not appear to be a pinhole leak to me. I first noticed this around 2019. Unfortunately the video is MP4 and I cannot upload it.”

“The contact owns a 2017 Hyundai Sonata. The contact stated that the vehicle experienced excessive oil consumption with an abnormal burning odor. The vehicle was taken to a dealer, and an oil consumption test was performed. The contact was informed that the vehicle passed the inspection. While driving later, the vehicle stalled and was taken back to the dealer, where it was determined that the vehicle was consuming an excessive amount of engine oil, and several DTC including the Knock Sensor Detection System (KSDS) were found. The contact stated that while driving or reversing at various speeds, the vehicle shuddered, made abnormal rattling sounds, entered HEV Lock Mode, and the vehicle stalled. The vehicle occasionally came to a complete stop in the middle of the road and had to be pushed out of the roadway. On other occasions, the driver was able to pull over to the side of the road. The vehicle failed to restart and was towed after stalling. The contact stated that the check engine warning light was illuminated before the vehicle entered HEV Lock Mode, with several unknown warning lights illuminated. The vehicle was towed to the dealer, where several tests,…”