2023 Jeep Gladiator problems

“I believe it is the blend door actuator, the heat when on defrost automatically switched between hot to ice cold which fogs up windows and causes other issues. Brought the vehicle in for for the current recall along with service on this, and this was not looked at. When the temp changes the A/C is turned off and temp is turned up to clear the window. It starts blowing ice cold air that fogs up the window almost instantly”

“Vehicle has been in the shop at 17,000 miles and had a complete transfer case, front and rear output shafts and rear Danna 44 (Max Tow) replaced in November of 2025. In June of 2025 vehicle has been in another shop for the same issues that occurred before these driveline repairs for three weeks now. Shop can not diagnose issues after three weeks. A star report has been made and Jeep is sending a technician to diagnose.”

“The contact owns a 2023 Jeep Gladiator. The contact received notification of NHTSA Campaign Number: 26V363000 (Steering); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure.”

“while completly filling the vehicle with gasoline, fuel sprays out of teh filler neck onto the vehicle and ground. This has happened many times, at reputible gas stations (Costco, Sams, walmart, Loaf and Jug). Dealership replaced original filler tube. But problem still exists. Shared video with dealership and they indicated they had no problems Castle Rock Jeep, Castle rock, COlorado”

“The vehicle does not have linerar acceperation. At times from a start, cold or warn engine, the vehicle will abruptly accelerate harder than the gas pedal was pressed. at light throttle, the vehicle will surge, shutter or chug. Erattic acceperation. after the engine replacement for a connecting rod bearing failure, the engine was running rough, poor mileage and stalled on a wet and cold morning (32degrees, raining). The stall happened on the deaccel lane of the interstate 25 (65 mph). THe dealership replaced one injector and said the problem was fixed. But it is not. Vehicle has not stalled, but we have not had the cold/wet weather.”

“5800 miles, the engine failed due to a connecting rod failure. Chrysler replaced the engine at no cost. Oil changes were done at the year mark as the mileage limit was not reached. Dealership indicates they replace several 3.6 engines a month for warranty failures Castle Rock Jeep, Castle rock Colorado.”