1996 Jeep Grand Cherokee visibility problems

“TL* THE CONTACT OWNS A 1996 JEEP CHEROKEE. THE CONTACT STATED THAT THE HEATING UNIT WAS ACTIVATED AND THE VEHICLE BEGAN TO MISFIRE. THE CONTACT LIFTED THE HOOD AND FOUND THAT THE SWITCH FOR THE HEATING FAN HAD FAILED AND A SMALL FIRE STARTED FROM UNDER THE HOOD. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE PART NEEDED FOR REPAIRS WAS NO LONGER BEING MANUFACTURED. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 167,275.”

“I HAVE A 1996 JEEP CHEROKEE. THE HEATER STARTED MAKING A FUNNY NOISE SO WE BOUGHT A NEW BLOWER MOTOR. THEN WE BOUGHT A NEW RESISTOR. WE STILL COULD NOT GET THE SPEEDS TO WORK IN THE HEATER. SO WE THEN BOUGHT A SWITCH. WELL WE COME TO FIND OUT THAT THE SWITCH HARNESS WAS BURNT TO A CRISP. I CALLED THE PARTS STORE AND THEY DON'T CARRY THEM, SO I THEN CALLED A DEALER. THE DEALER TOLD ME THEY DON'T JUST SELL THAT HARNESS I HAD TO BUY THE ENTIRE ONE FOR EVERYTHING IN THE JEEP. THEN TOLD ME TO GO CUT ONE OUT OF A JUNK YARD. I CALLED MY LOCAL JUNK YARD AND THE GUY WENT AND CUT THREE HARNESSES OUT. ONE THAT WAS A 1996, ONE THAT WAS A 1995, AND BOTH OF THE ENDS WERE BURNT JUST LIKE MINE. HE THEN CUT ONE OUT OF AN EVEN OLDER ONE, AND THE WIRES WERE THICKER THAN THE ONES ON MINE, AND DIFFERENT COLORS. I TRIED HOOKING IT UP AND IT DOESN'T WORK. I BELIEVE THAT SHOULD BE A RECALL AND IT SHOULD HAVE TO BE REPLACED BY THE COMPANY. THE COMPANY SHOULD ALSO SELL INDIVIDUAL HARNESSES. *TR”

“96 JEEP CHEROKEE HEATER FAN SPEED CONTROL SWITCH FAILED. FOUND SWITCH AND WIRING CONNECTOR TO BE MELTED. REPLACEMENT UNIT FROM JUNK YARD HAD EXACT SAME DEFECT. APPEARS TO BE A COMMON PROBLEM. *TR”

“PROBLEM... DRIVING DOWN THE ROAD OR STOPPED AT LIGHT OR IN THE MIDDLE OF A TURN OR ON EXPRESSWAY... IT WOULD SHUT OFF WITHOUT WARNING, SOMETIME IT WOULD RESTART IMMEDIATELY, SOMETIMES NOT!!!... EXTREMELY DANGEROUS SITUATIONS DEVELOPED, WHICH I WAS LUCKY!!! 1996 JEEP GRAND CHEROKEE, 4.0 , 6 CYL.... SPENT 6 MONTHS DOING REPAIRS/ REPLACEMENT PARTS AND MANY ,MANY DOLLARS SPENT TRACKING DOWN PART AFTER PART. USING DIAGNOSTICS MACHINE TO DETERMINE FAULTY PART... PROBLEM WAS THE POWER CONTROL MODULE ( PCM OR ECU SAME PART) WAS DEFECTIVE AND EITHER WAS MISREADING CODES OR GIVING OUT BAD CODES TO PARTS (LIKE TO THE CRANK SHAFT POSITION SENSOR OR THE COIL, OR THE 01 OR 02 OX SENSORS OR IT GOES ON AND ON AND ON). NOT SURE HOW IT WORKS BUT YOU GET MY DRIFT. SINCE SIGNING UP WITH CNET.COM, HAVE FOUND MANY PEOPLE ACROSS AMERICA WITH THE SAME ISSUE ON JEEP WITH DIFFERENT YEARS (1994/2000) AND MODELS. TO SEARCH... LOOK UP JEEP STALLS OR JEEP FIXED AND YOU WILL SEE OTHER TOPICS AND FORUMS AROUND THAT TOPIC AND YOU WILL ALSO SEE WHERE THE MANUFACTURE DOESN'T KNOW HOW TO ADDRESS THE PROBLEM EITHER. ANOTHER POSSIBLE RECALL ISSUE IS THE SCREWS THAT HOLD THE PCM MIGHT BE TOO LONG…”

“WHILE DRIVING 20 MPH CONSUMER NOTICED THAT THE REAR LIFTGATE OVERHEATED. IT ONLY HAPPENED WHEN ANOTHER VEHICLE WAS BEHIND. THIS CAUSED POOR VISIBILITY TO THE DRIVER. CONSUMER WILL CONTACT THE DEALER IN THE NEAR FUTURE. *AK”

“FLOODING WATER IS ENTERING DRIVER'S SIDE OF VEHICLE. ALSO, ICE IS FORMING ON INSIDE OF WINDSHIELD. CONSUMER HAS CONTACTED DEALER. *AK ALL 4 GOODYEAR WRANGLER TIRES WITH LESS THAN 13000 MILES HAD TO BE REPLACED. CONSUMER STATES THAT THE SERVICE MANAGER WILL NOT RETURN THE CALLS CONCERNING MAKING AN APPOINTMENT TO HAVE VEHICLE FIXED, DEALER IS REQUESTING THAT CONSUMER PAY FOR ALL REPAIRS, LABOR, AND PARTS. *SLC”