1997 Jeep Wrangler suspension problems

“MY FRAME IS ROTTING FROM THE INSIDE OUT. THE REAR TRAILING ARM MOUNTS ARE WELDED TO THE FRAME AND THE FRAME ROTTED THROUGH FROM THE INSIDE OUT. THE VEHICLE WILL NOT PASS THE REQUIRED SAFTEY INSPECTION. I STARTED LOOKING FOR A WAY TO REPAIR/REPLACE THE FRAME AND FOUND THAT THIS IS A COMMON PROBLEM. THE COST OF REPAIR WILL EXCEED THE VALUE OF THE VEHICLE. THE DATE I HAVE ENTERED IS THE DATE THE PROBLEM WAS FOUND.”

“NOTICED WOBBLE UNDERNEATH WHILE DRIVING. INSPECTED UNDERNEATH AND NOTICED LIGHT SHOWING BETWEEN TRANSFER CASE SKID PLATE AND FRAME (SHOULD BE TIGHT) AND BOLT HANGING DOWN. TOOK INTO SHOP AND LOWER MID FRAME ON BOTH SIDES IS COMPLETELY RUSTED THROUGH ALLOWING SKID PLATE BOLTS TO FALL OUT WITH NUTS STILL ATTACHED. SKID PLATE ALSO SERVES AS TRANSFER CASE MOUNT AND WHEN IT DROPS THE DRIVESHAFT WOBBLES. ULTIMATELY IF IT HAD COMPLETELY LET GO ON THE HIGHWAY THE REAR DRIVESHAFT WOULD HAVE LOCKED UP AND LOCKED THE REAR WHEELS CAUSING UNCONTROLLED SKID, OR THE DRIVESHAFT WOULD BREAK CAUSING DANGER TO THE PASSENGERS.”

“DRIVING DOWN THE ROAD THE REAR UPPER CONTROL ARM BRACKETS SEPARATED FROM THE FRAME AS A RESULT OF THE FRAME CORRODING FROM THE INSIDE OUT. THIS CAUSED THE REAR BRAKE LINE TO BRAKE DRAINING THE MASTER CYLINDER. *TR”

“WHILE DRIVING MY JEEP ON A PUBLIC ROAD GOING ABOUT 45, THE VEHICLE BEGAN TO SHAKE UNCONTROLLABLY. I HAD TO PULL OVER AND STOP THE VEHICLE IN ORDER FOR THE SHAKING TO STOP. IT WAS INCREDIBLY DANGEROUS, AND I WAS LUCKY THAT I WASN'T INVOLVED IN AN ACCIDENT. *TR”

“THE FRAME IS ROTTING AWAY, THE FRAME ROT CLEARLY STARTED MANY YEARS AGO. THE RUST IS QUITE BAD AND WILL NOT STOP. IN AN ACCIDENT, THE BODY COULD POSSIBLY FLY OFF THE FRAME POSSIBLY BEING FATAL. THE FRAME IS RUSTING FROM CONTROL ARM BRACKETS TO BODY MOUNTS ALL OF WHICH CAN LEAD TO VERY DANGEROUS SITUATIONS. *TR”

“VIOLENT WOBBLING OF FRONT OF JEEP , IT COMES AND GOES AT DIFFERENT SPEEDS AND YOU MUST COME TO A SUDDEN STOP TO AVOID LOOSING CONTROL OF VEHICLE . I DON'T KNOW WHAT IS CAUSING THIS AS THERE IS NO APPARENT DAMAGE TO REPAIR. IN MY OPINION IT IS A FACTORY DEFECT AND THE VEHICLE IS UNSAFE FOR USE ON PUBLIC ROADS AND HIGHWAYS. *TR”