2022 Kia Sorento electrical system problems

“The contact owns a 2022 Kia Sorento. The contact received notification of NHTSA Campaign Number: 25V649000 (Electrical System, Visibility), and the vehicle was taken to the dealer; the recall repair was performed several weeks prior; however, the VIN status was not updated, and the recall remained marked as incomplete. The contact stated that the manufacturer had exceeded a reasonable amount of time to update the VIN status to reflect the completed repair. The manufacturer was notified of the issue.”

“The contact owns a 2022 Kia Sorento. The contact stated that while driving at an undisclosed speed, the Auto Hold feature activated, and the check engine warning light and several other unknown warning lights illuminated. The vehicle was taken to an independent mechanic, and DTCs U0164, U0123, U01B0, and U1131 were retrieved. The independent mechanic stated that the battery needed to be replaced. The independent mechanic also informed the contact of an unknown recall; however, the VIN was not under recall. The vehicle was repaired; however, the warning lights illuminated, and the failure persisted. Additionally, the parking brake warning light was illuminated. In addition, the air conditioning system was leaking refrigerant and intermittently was blowing out hot air. The A/C started blowing colder air minutes later. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 69,900.”

“The electric oil pump circuit board for the transmission failed, causing motive power loss. The vehicle is currently located at Ourisman Chantilly Kia and is available for inspection. Safety was compromised due to sudden loss of drive power while operating on public roads, creating a severe crash hazard. The failure was diagnosed and confirmed by Ourisman Chantilly Kia service department, which retrieved active Diagnostic Trouble Code P1C2D03. The vehicle was inspected by the Kia dealership service department. Prior to failure, check engine/warning lights illuminated and transmission drive symptoms appeared. This vehicle is subject to Recall SC250. A software update was performed under a previous owner, but the physical component failed. Kia is refusing replacement because the recall was marked "closed" after the software patch, leaving a known unaddressed safety defect active on the vehicle.”

“The Auto Start-Stop System light came on flashing while driving. Vehicle wouldn’t accelerate while in heavy traffic. Pulled over to the shoulder and turned vehicle off. Attempted to start vehicle again and would not start. Had to get the vehicle towed. Positive battery post is loose and screw is tightened as much as possible.”

“I own a 2022 Kia Sorento that was manufactured on January 13, 2022. My vehicle experienced a failure involving the electronic oil pump within the transmission system. While driving, a transmission error message appeared prior to the failure. Shortly after, the vehicle unexpectedly entered a limited-mobility condition and significantly slowed down, operating only at a reduced speed. This created a hazardous situation, as I was unable to maintain normal traffic flow, increasing the risk to myself and other drivers. The issue has been diagnosed and confirmed by a service center as a malfunction of the electronic transmission oil pump. I am aware that Kia Motors has issued a recall for certain 2021–2022 Sorento and 2021–2023 K5 vehicles related to a defect where the fail-safe limited-mobility drive mode may be impaired due to a transmission oil pump malfunction, potentially resulting in a complete loss of drive power. Although my vehicle appears to have been manufactured during the same timeframe as the affected vehicles, it has not been included in the recall. The failure I experienced is consistent with the conditions described in that recall. The vehicle has not…”

“The fuel door actuator failed. The gas door would not open due to the actuator being seized shut, preventing access to the fuel tank. This vehicle does not have a manual release mechanism, so there was no alternative way to open the fuel door. The dealership confirmed the actuator malfunction. My family’s safety was put at risk because we were unable to refuel the vehicle. The incident occurred during extremely cold weather, with a windchill of approximately -8°F. Due to the inability to add fuel, we were at risk of running out of gas and losing heat in the vehicle, which could have resulted in a dangerous exposure situation. There were no warning lights or messages indicating a problem prior to the failure. The issue was first noticed when attempting to refuel and the fuel door would not open.”