2012 Kia Soul engine problems

“2012 Kia Soul 1.6L GDI (VIN: [XXX]). Case #[XXX]. Safety Hazard Description: The vehicle experienced a sudden engine stalling event at highway speeds and repeatedly dropped into a restricted "Limp Mode" due to a recurring P1326 diagnostic code. This code is explicitly tied to Kia's Knock Sensor Detection System (KSDS) monitoring structural connecting rod bearing failure. The sudden loss of engine RPMs and throttle response created a severe traffic hazard, leaving me without power steering or predictable acceleration in active traffic. Dealer Information & System Non-Compliance: The vehicle is currently grounded and unsafe to drive. Southlake Kia (Merrillville, IN) verified that the vehicle's engine sensor and circuit are operating perfectly with an end-to-end wiring test reading at a flawless 0.2 OHMS (Repair Order #[XXX]). This mathematically confirms that the sensor is picking up real, severe internal mechanical vibrations from a failing engine block rather than an electrical short circuit. Official internal dealer records (R/O #[XXX]) prove that this severe engine defect initially manifested and was documented at 149,715 miles—strictly under the 150,000-mile…”

“The contact owns a 2012 Kia Soul. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. No warning lights were illuminated. The vehicle was driven to the residence. The contact stated that the following day, while attempting to start the vehicle, the vehicle started, and the check engine warning light was off. The vehicle was taken to the dealer, where the contact was informed that the recall repair failure code was not illuminated. In addition, the contact was informed that the failure was not covered under a recall. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact received a recall notification, NHTSA Campaign Number: 19V120000 (Engine, Engine and Engine Cooling). The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 156,310.”

“The contact owns a 2012 Kia Soul. The contact stated that while driving at 60 MPH, the vehicle unexpectedly stalled and failed to accelerate with the low oil warning light illuminated. The contact stated that the failure occurred after the contact’s spouse had added oil to the vehicle. The vehicle was able to restart, and additional oil had to be delivered to the contact to refill the vehicle. The dealer was contacted. The vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure and advised the contact to have the vehicle diagnosed by a dealer for further assistance. The approximate failure mileage was 84,213.”

“Check engine light came on. Car starts to shutter upon acceleration as well when its idling. Changed spark plugs 3 times since Jan 2025 and coils twice. Code for engine misfire in cylinder 3. Also have to add oil every 2 weeks.”

“On Oct. 14, 2025, this vehicle experienced a sudden catastrophic engine failure while driving approx. 70 mph on a highway. While in the passing lane, the vehicle began to lose power, shake, and wouldn’t accelerate. The check engine light came on just moments before a loud explosive noise came from the engine, and a burning smell came through the vents - the engine completely shut down. This failure occurred with other vehicles on the roadway, creating a serious safety risk. I was forced to quickly maneuver the disabled vehicle across multiple lanes of traffic to reach the right shoulder, where I called for roadside assistance. The vehicle was inoperable from that point forward, it would not turn on, and was towed from the scene. There were no warning signs prior to this event. The vehicle had been operating normally before the incident - I had recently checked the oil levels, there were no warning lights, no drivability issues, and no known mechanical problems before the sudden failure. This led me to find the vehicle was subject to an open safety recall addressing engine damage consistent with this failure; NHTSA Recall 19V120000. On Oct. 27th, the vehicle was…”

“On 12/ 22/ 2025 I went to start the 2012 KIA Soul and it would act like it would start but, it would not turn over. Battery was fine checked it. Let it set a moment and tried it again would not start. Called a wrecker and towed it in. The service guy tried and couldn't get it to start either. He ran a diagnostic on it, there were not type of codes, no check engine light nothing. He had it for until 1/5/2026 and when they went to check it it started right up. They drove it for 20 miles to check to see if it would cut off while driving, it didn't. It starts now but for how long. Here's the strange thing, I drove it 20 minutes away and I noticed that the counter for when You fill up with gas states how many miles you have left to go before fill up was counting UP not DOWN. So I think it could be the computer or electrical, I thought it was the fuel pump at first. Still no warning signals nothing.”