2019 Land Rover Range Rover Velar problems

“My 2019 Range Rover Velar P250 R-Dynamic SE began experiencing cooling system issues approximately 5 months after purchase. The vehicle was brought to an authorized Land Rover dealership several times during the warranty period. Despite these visits, the underlying problem — including cracked thermostat housing, leaking coolant hoses, and plastic cooling system components — was never permanently repaired. Over time, the unresolved defect caused catastrophic engine and turbocharger failure, which I paid for out of pocket. The cooling issues are consistent with known Land Rover service bulletins covering: “Thermostat housing / coolant outlet leaks”, “Coolant crossover pipe / O-ring leaks”, “Turbocharger coolant pipe leaks”. The defect substantially affects vehicle reliability, safety, and value. I have attached: Dealer repair orders, Independent shop invoices for cooling repairs, engine and turbocharger replacement invoice, timeline of events showing repeated repair attempts and resulting failures.”

“As I was driving down the interstate doing about 75 miles per hour the car lost all power without a warning. It was at night in the middle of no where. I almost had a bad accident but I was able to veer off the road before the car brakes locked. I was unable to use safety flashers.”

“I am reporting a premature failure of the daytime running light (DRL) system on my Range Rover Velar. Both DRLs have failed within approximately one year of each other, indicating a likely systemic defect rather than normal wear. The DRLs are integrated LED components within the headlamp assembly and are not serviceable independently. When the DRL fails, the entire headlight assembly must typically be replaced. I have been informed that a single replacement headlight assembly can cost approximately $3,000 (parts only, excluding labor). This results in an extremely high repair cost for a lighting component that should last the life of the vehicle. When one DRL fails and the other remains operational, the vehicle presents uneven forward lighting, where one side is illuminated and the other is not. This creates an inconsistent lighting signature and may not meet federal lighting performance and visibility expectations. This asymmetry can impair other drivers’ ability to accurately perceive the vehicle’s position and width, especially in low-visibility daytime conditions such as rain or fog. The failures occurred without any physical damage or external cause,…”

“My husband and I were going to the highway and the rear end of the passenger side portion fell apart. I'm still shocked from the weekend incident. My husband and a good friend of ours are working for Big 3 is Vehicle Safety and never ever saw this kind of an incident. Tow truck driver Richard who towed our car witnessed that they never saw this kind of damage. Range Rover retailer is not very receptive except that it is a tire issue and is not covered under warranty. This is my first time buying this Range Rover and I had a horrible experience. While we investigate further to determine the root cause of this incident, Would like to see the FMEA. I don't want this to happen to anyone and I will not be interested in driving this car. Would you be able to share any previous incidents similar to this? Would you please be able to escalate this to the next level of customer satisfaction? Thank you for your prompt response. Do you hvae an email we can upload the pictures and video?”

“The contact owns a 2019 Land Rover Range Rover Velar. The contact stated that while driving at an undisclosed speed, the vehicle overheated. The low oil pressure warning light and the check engine warning light were illuminated. The vehicle was taken to the dealer, where it was diagnosed that coolant intrusion into the engine had caused the engine to fail. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 56,000.”

“Driver side door will not lock. I took it to the dealership and they replaced the door handle and it worked for a little while. The vehicle locks after you start driving but when you unlock or open the door you can’t relock the car. This is a safety issue. I have taken it to many repair shops and they say it is not the mechanism, it is the software issue. Land Rover continues to say it is not. I have found that many people have had the same issue on different forum.”