2014 Lexus CT200H problems

“common problem with these Lexus ct200h, as well as Toyota Prius V models, are that the brake accumulators begin to leak internally, as they share the same part numbers. Therefore, the actuator will buzz every few seconds trying to keep pressure in the braking system to a safe operating level of gas pressure to no avail due to this leak in the actuator. After it quits buzzing from shutting the car off, you can hear the air leak hissing the pressure away. There are tons and tons of articles on this issue online as this is a major safety concern. Many have had Toyota replace the part free of charge as well due to the extended 10 year, or 150k miles, in whichever comes first. warranty. This may be perhaps because there are several more prius on the road than this rare Lexus CT200H. Just look up “c1391 danger” and see what comes up. In my opinion, as well as many, it is pathetic that an issue in which endangers the lives of others due this brake failure is not further addressed. There is Not much stopping distances when and after this suddenly occurs. In the process, the abs, traction control, brake, a yellow exclamation mark, lights suddenly all come on the dash at…”

“I’m reporting a serious safety issue with my 2014 Lexus CT200h involving the brake booster and ABS pump/accumulator system. This issue is well-documented across Lexus CT200h and Toyota Prius V models, which use the same components. Lexus quietly issued a Customer Support Program (CSP) for the affected part but never notified me. I contacted Lexus and was told they “didn’t have to” notify all owners. After escalating, they claimed a letter was sent, but I confirmed my address and never received anything. Several months before the CSP expired, I noticed inconsistent brake response, a soft/spongy pedal, and warning lights: ABS, traction control, brake, and TPMS. I took the car to an independent mechanic who misdiagnosed it as a TPMS issue. Six months later, a loud chime began sounding repeatedly, unrelated to seatbelt use. I brought the car to Lexus of North Miami, where they diagnosed a failing ABS pump and accumulator — the exact components covered by the CSP. This is a critical safety failure. Loss of braking pressure compromises stopping distance and puts my safety and others at risk. Lexus refused assistance because the CSP expired, even though the problem…”

“Engine started misfiring recently at engine cold start and from hybrid transition to engine startup. Engine light came on with reports codes P0302 and P0304. Additionally, another error code P0607 also was detected. Had a certified mechanic assess the car and replaced the four coils for the CT200h. No change in issue. New issue developed this past Monday with an engine temperature light flashing on. Stopped and put a half liter in the coolant reservoir. Engine temperature light did not come back on. Took the car to a certified mechanic and told him to pressure test the coolant system. The mechanic confirmed the head gasket is blown. In the Lexus CT200h online forum there is a clear and compelling case that the EGR malfunctioned and directly contributed to the head gasket blowing. This car has approximately 128,000 miles. I would encourage you to read the Lexus CT 200h forum.”

“ABS, TRACTION CONTROL , BRAKE, A YELLOW EXCLAMMATION POINT, RED BRAKE LIGHT ALL COME ON, AS WARNING LIGHTS ON THE DASH BOARD, AND THE BREAKS START TO FEEL SPONGEY AND NOT WORK AS WELL. THE ACTUATOR STARTS TO BUZZ EVERY FEW SECONDS TRYING TO KEEP PRESSURE IN THE BRAKING SYSTEM, BUT IT CANNOT DUE TO A LEAK IN THE ACCUATOR, IN WHICH THEN CAUSES THE ABS SYSTEM TO DEACTIVATE, A KNOWN PROBLEM OF THE LEXUS CT200H, MANY OF THE OTHER LEXUS HAD THIS PROBLEM AS A RECALL AS WELL- LEXUS SHOULD BE FIXING THIS FOR PEOPLE ITS A MAJOR SAFETY ISSUE THAT THE BRAKES START TO NOT WORK OUT OF NO WHERE AND ITS NOT FAIR TO THE OWNER TO BE RESPONSIBLE FOR THIS ENORMOUS BILL TO FIX WHEN ITS A KNOWN PROBLEM OF LEXUS! IT STATES ONLINE ALL OVER THE PLACE THAT CT200H VEHICLES MAY HAVE BRAKE, ABS AND OR TRAC WARNING LIGHTS ON OR A CHECK VSC MESSAGE DISPLAYED DUE TO A SMALL BRAKE FLUID LEAK INSIDE THE BRAKE BOOSTER ASSEMBLY WITH MASTER CYLINDER, ABS ACTUATOR FAILURE, AND ONLINE LISTS ALL THE CODES. IT SAYS IF THE CONDITION IS VERIFIED THE VEHICLE WILL BE REPAIRED WITH NEW BRAKE BOOSTER AND BRAKE BOOSTER PUMP ASSEMBLIES BUT NOT ALL LEXUS ESTABLISHMENTS ARE COOPERATING WITH THIS, AND ITS NOT SAFE!”

“My daughter was involved in a rollover accident 10/24/2023 resulting in a front passenger injury. The passenger's right hand was crushed during the accident requiring a lengthy hospitalization and numerous hand surgeries. The passenger will require additional surgeries in the upcoming future. Front and side airbags was not deployed during the accident. No warnings on the dash re. airbag issues prior to the accident. The car was released to USAA (ie. adjuster) and car was deemed unfixable.”

“The contact owns a 2014 Lexus CT200H. The contact stated while driving 20 MPH, the brake pedal became firm while depressed. The ABS and traction control warning lights illuminated. The contact coasted the vehicle into parking lot, stopped, and turned off the vehicle. Due to the failure, the vehicle was towed to the residence and later to a local dealer. The contact was informed by the dealer that the brake pump assembly and brake cylinder needed to be replaced. The manufacturer was notified of the failure and the contact was informed that the vehicle was not under warranty or recall. The vehicle was not repaired and remained in the possession of the dealer. The failure mileage was approximately 100,500.”