2012 Mazda CX-9 service brakes problems

“I was driving normally when I started sowing down and noticed the brakes were harder to push. I finally stopped just before almost rear-ending a vehicle in front of me. It turns out the brake booster, a known problem that was not communicated to me a few years ago, failed and makes braking the vehicle harder, increases distance, and makes the vehicle unsafe to drive. The problem has been reproduced via a diagnostic test at Mazda of Gladstone dealership on 9/27/23. The dealership has been the only people who have inspected the issue. There were no warning signs, no warning lights, nothing. It was scary because I didn't think my vehicle was going to stop. It's completely dangerous. I have not gotten the vehicle repaired yet because I believe Mazda holds responsibility as this has been a known issue with their cars.”

“On August 14, 2020, the brake booster along with the master cylinder failed, resulting in very dangerous and frightening driving conditions, and the parts were replaced with Mazda original parts. This was an ongoing issue with the Mazda CX-9’s. I reported it to the NHTSA, complaint number 11480067. On January 4, 2023, the brake master cylinder and booster failed again resulting again in very dangerous and frightening driving conditions. The car was driven only 25,383 miles before the brakes failed the second time. The Mazda parts were defective and continue to be so after many years with no effort by Mazda to improve these parts. Attached are the repair invoices for both incidents. I have tried contacting Mazda and they refuse to address the issue.”

“The brakes suddenly became very difficult to press as if I did not have power brakes. No warning lights came on and it became very difficult to stop the car. Then if I had to break suddenly and hard it would stall. I brought it to the repair shop and the brake booster was defective. The brake booster along with the master cylinder had to be replaced. It was a very dangerous and frightening experience the brakes suddenly difficult to use. I contacted Mazda customer service and they did not care. I then tried to escalate the issue over the last two years but it was impossible to contact anyone and all emails came back undeliverable. I just recently learned that I can report this danger to the NHTSA.”

“This is relating to NHTSA Investigation PE 14-005. Although this car is a 2012 Mazda CX9, my wife driving the car had the same issue where she heard a hissing noise and the brakes were very difficult for her to depress or to stop. A brake issue is a major defect where the NHTSA should have initiated a recall in accordance with 49 U.S.C. 30118-30120, which required notification of all owners. Why the NHTSA allowed Mazda to only issue a 'Special Extended Warranty' is beyond me, and smells of a back door deal. Nonetheless, I was unaware of this issue with the Mazda CX9's as I was never notified. My wife drove the vehicle home and I purchased the replacement parts at my own expense. This should be a full recall and should be reopened as your current investigation PE 14-005 only included years 2010-2011, and did *not* include the 2012 model year.”

“Brake booster failure caused a near miss. Wife driving with 5 year old daughter in the vehicle. The stopping force required on the brake pedal became excessive and the stopping (safe braking) distance significantly increased causing emotional distress. My understanding is this part (brake booster) has a defective diaphragm that deteriorates over time. The extended warranty created for this particular issue did not cover the vehicle at the time of the failure.”

“BRAKE BOOSTER INTERNAL FAILURE - This is a known issue and a safety hazard on Mazda CX 9 models and should be investigated again regardless of the age of the vehicle.”