2009 Mercury Milan service brakes problems

“I RECEIVED A LETTER IN JULY OF 2021 ABOUT THE ABS CONTROL UNIT PROBLEM MY VEHICLE HAS. AT THE MOMENT THAT CONTROL MODULE IS NON-FUNCTIONAL. TO DATE FORD HAS NOT PRODUCED OR MADE AVAILABLE ANY OF THE PARTS NEEDED FOR THIS REPAIR AND WILL NOT EVEN ACKNOWLEDGE THE VEHICLE WHEN I CALLED THEM. I WOULD LIKE TO KNOW HOW LONG I HAVE TO DRIVE A VEHICLE WITH KNOWN DEFECTIVE BRAKES BEFORE FORD IS FORCED TO COMPLETE THIS REPAIR? THERE IS ALSO A BRAKE FLUID ISSUE WITH THIS VEHICLE THAT CANNOT BE ADDRESSED UNTIL THE NON-FUNCTIONING ABS MODULE IS REPAIRED. THE DEALER REFUSED TO CHANGE THE SAID CORROSIVE FLUID BECAUSE OF THE NON-FUNCTIONING ABS MODULE.”

“Brake pedal going to floor extending stopping distance. Early in 2022 I took it in for recall S1954. HCU passed test and dealer replaced DOT3 brake fluid with DOt4. 5/24/2022 Brake pedal started going to floor again. Dealer performed self test of hcu and electronic bleed hcu and said pedal was somewhat better but needed $400 of brake work to for Brake pads, lining and turn rotors. Car functioned fine for a few days. In early June I was driving on a wet street and put on the brakes. It appeared the ABS system was trying to kick in and suddenly the pedal again went to the floor. I was barely able to miss rear-ending a city bus. I pulled into a gas station, turned the car off. When I started it again the brake pedal went to the floor. After pumping it a number of times it came back up and was again functioning. Took it to dealer on 6/1/22. Dealer again tested the hcu test which once again it passed. They could find no other problems. Dealers recommended replacing the abs modlule and master cylinder to the tune of $1,400. Seems like they can test and find out which part isn't malfunctioning (hcu which is under recall), but cant test to find out which part is…”

“The problem I am having is with the cars braking system. I have extended brake travel required to stop the vehicle for which I have been issued two recalls. Because of the extended brake travel, I was unable to stop in time and had a front end collision with minor damage, which was not reported. The problem first showed up when I was forced to brake hard a few years causing the ABS to engage. The brake pedal traveled to the floor until the next time the ABS was engaged. Shortly after that, I was issued a recall stating the exact problem I was having. When I took it to my local dealership to get it fixed, they performed a test, changed the brake fluid, and said the system was working properly. It was not. Took it back to the dealership when hydraulic control valve became permanently locked open. They inspected it again and said the ABS unit needed to be replaced but the parts were not available. Contacted FMC customer service, and they were unable to help me either. I asked for a loaner vehicle, and received no response. Since then, I have been issued another recall and am still driving an unsafe car in a Michigan winter. All I want is a safe car to drive.”

“Manufacturer Recall Number19S54 NHTSA Recall Number19V904 This recall has been on file since: Dec 18,2019. There is still no remedy. I believe this issue is causing my vehicle to have significant delays in braking into a complete stop. The manufacturer has failed or is unable to remedy this safety recall for my vehicle in a timely manner, so I would like to file a formal complaint.”

“TL* THE CONTACT OWNS A 2009 MERCURY MILAN. THE CONTACT STATED WHILE HER HUSBAND WAS DRIVING 25-30 MPH, THE BRAKE PEDAL WAS DEPRESSED TO THE FLOOR BOARD AND WAS SLOW TO RESPOND. THERE WAS NO WARNING LIGHT ILLUMINATED. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.”

“TL* THE CONTACT OWNS A 2009 MERCURY MILAN. THE CONTACT STATED THAT WHILE DRIVING VARIOUS SPEEDS, HER BRAKE PEDAL WOULD DEPRESS TO THE FLOORBOARD WITHOUT WARNING. THE CONTACT INITIALLY SPOKE TO AN INDEPENDENT MECHANIC WHO INFORMED HER THAT OVER TIME, HER BRAKE PEDAL WOULD DEPRESS TO THE FLOORBOARD. HE ALSO MENTIONED THAT AS LONG AS THE VEHICLE WOULD COME TO A COMPLETE STOP, NO NEED IMMEDIATE BRAKE SERVICES WOULD BE NEEDED. THE CONTACT WAS THEN NOTIFIED BY A COUSIN THAT HER VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 19V904000 (SERVICE BRAKES, HYDRAULIC). THE CONTACT THEN CALLED UNIVERSITY FORD NORTH (5331 N ROXBORO ST, DURHAM, NC 27712) WHERE SHE WAS INFORMED THAT THE PART WAS NOT YET AVAILABLE AND TO CALL BACK IN MID-MARCH FOR AN UPDATE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. *BF”