2009 MINI Clubman S problems

“I am writing to formally request reimbursement for a timing chain replacement performed on my vehicle, which was the subject of a specific safety recall issued by BMW. The timing chain defect in this vehicle represents a severe safety hazard, as a failure can cause an immediate and total engine stall while the vehicle is in motion. This loss of power in traffic creates an 100% avoidable risk of collision. Despite BMW recognizing this defect through a prior reimbursement program, they are refusing to compensate for a safety-critical repair on a low-mileage vehicle (58,XXX miles) simply based on the car's age. At the time of repair, the vehicle had approximately 58,XXX miles. Although the vehicle is older, it was in storage for several years because the previous owner was unaware of the recall and lacked the financial means to address it. Despite the period of storage, the car remained in excellent condition, with the timing chain being the only mechanical requirement at the time. The repair was completed by a local independent shop and paid for out-of-pocket. While BMW has recently honored a different recall for an electronics panel on this same VIN, my request…”

“DRIVING ON THE INTERSTATE APPROXIMATELY 70MPH, SUDDENLY VEHICLE BEGAN RUMBLING. IMMEDIATELY CHECK ENGINE LIGHT FLASHED AND THE CAR IMMEDIATELY STOPPED ACCELERATING. THE MOTOR KEPT RUNNING BUT WITH A CONTINUOUS RUMBLING AND ACCELERATOR WAS COMPLETELY INACTIVE. CAR WILL START BUT NO POWER OUTPUT, PRESSING ON THE GAS IS FUTILE.”

“The contact owns a 2009 Mini Cooper S Clubman. The contact stated while driving at an undisclosed speed, the contacted became aware of a failure with the electrical system. The contact stated that the instrument panel failed to display as needed, and the turn signals failed to function properly. The contact also stated that while the vehicle was parked, the vehicle failed to turn off, causing the battery to become drained. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The failure mileage was approximately 75,000. VIN tool confirms parts not available.”

“RECALL CAMPAIGN NO: 12V-008 ELECTRIC AUXILIARY WATER PUMP HTTP://WWW-ODI.NHTSA.DOT.GOV/DEFECTS/RESULTS.CFM THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION WEBSITE SAYS WE ARE ALSO NOTIFIED TO TAKE THE VEHICLE TO A BMW DEALER FOR REPAIR. WHY CANNOT I NOT DO THIS? WE HAVE A BMW DEALER IN BOISE. OWNERS OF THE RECALLED VEHICLES ARE NOTIFIED TO TAKE THEIR VEHICLE TO A BMW DEALER, WHO WILL REPLACE THE AUXILIARY WATER PUMP TO PREVENT ANY INCIDENTS RELATED TO THIS ISSUE. THIS PRELIMINARY EVALUATION IS CLOSED. THE ODI REPORTS CITED ABOVE CAN BE VIEWED AT WWW-ODI.NHTSA.DOT.GOV/COMPLAINTS UNDER THE FOLLOWING IDENTIFICATION NUMBERS (ODI NOS.): 10286597, 10286663, 10289793, 10310677, 10314796, 10342365, 10394808, 10394192, 10403982, 10418325, 10422646, 10429003. I CANNOT TELL YOU HOW MANY HOURS I HAVE SPENT ON THE PHONE WITH MINI, MINI OF MURRAY, AND MINI ROADSIDE ASSISTANCE, MY LOCAL BMW DEALER, AND SEVERAL REPAIR SHOPS AND A TOW TRUCKING COMPANY.MINI IS COMPLETELY LEAVING THOSE CUSTOMERS IN THE LURCH THAT DO NOT HAVE MINI DEALERS IN THEIR STATE. NOW MINI OF MURRAY IS TELLING ME THAT IF I FIX MY CAR IN BOISE AFTER I HAVE RECEIVED THE RECALL NOTICE THAT I AM STILL ON THE…”

“PASSENGER AIRBAG SENSOR IS MALFUNCTIONING. THE PASSENGER AIRBAG SENSOR FAILURE RESULTS IN THE AIRBAG FOR THE PASSENGER SIDE BEING DISABLED WHEN THE CAR IS IN MOTION/DRIVING REGARDLESS OF WHETHER A PERSON IS SITTING IN THE SEAT (AN ADULT WILL BE SITTING IN THE SEAT AND THE AIRBAG WILL CONTINUE TO BE DISABLED AS THE CAR IS DRIVEN AROUND). THE LACK OF AIRBAG FOR THE PASSENGER OF THE VEHICLE DUE TO THE FAULTY SENSOR IS A SIGNIFICANT SAFETY RISK THAT WILL LIKELY RESULT IN THE DEATH OR SERIOUS INJURY. THIS APPEARS TO BE A PROBLEM MINI HAD ON OTHER MODELS OF ITS CARS WHICH RESULTED IN A RECALL.”

“GROWLING- RUBBING NOISE AUDIBLE AT LOW SPEEDS. AIR CONDITIONING HOSE HAD COME LOOSE AND WAS "BURNING" ON OTHER ENGINE PARTS. DEALER SERVICE STATED THIS WAS A VERY UNUSUAL CASE. CAR HAD BEEN IN FOR TENSOR CHAIN REPLACEMENT FIVE DAYS EARLIER. *JS”