2009 MINI Clubman problems

“REPLACED THERMOSTAT, HEATER STOPPED WORKING, VEHICLE OVERHEATED WHAT SEEMS TO BE A FAULTY WATER PUMP OR THERMOSTAT, CAR SMOKED INTENSELY DROVE SHORT DISTANCE- THERMOSTAT MELTED- MOTOR BLEW. THIS VEHICLE WAS WELL MAINTAINED***”

“I recently purchased a 2009 mini cooper clubman. Within three weeks of taking possession of the car, the airbag warning light activated. Upon a diagnostic test, it was determined that the passenger occupancy sensor was malfunctioning. After discussing this with the mini cooper dealer in my area and mini USA, it was acknowledged that this was a well known and documented issue. First generation mini coopers were afforded a safety recall to rectify this safety issue while second generation cars were given an extended warranty. Unfortunately, I am now driving a car outside of the extended warranty that was only offered to the original owner with a faulty airbag system for any passenger in my car. A recall MUST be issued for the second generation mini cooper to hold the company responsible for this faulty design. Owners of these cars are avoiding the $2500 repair bill by installing sensor bypass modules in order to clear the malfunctioning light warning. NHSTA is well aware of this problem as I have read hundreds of issues and concerns in mini cooper forums. Please address this problem as force the recall on the occupancy airbag sensor before a passenger is seriously injured or killed.”

“The contact owned a 2009 Min Cooper Clubman. The contact received notification of NHTSA Campaign Number: 23V337000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The contact stated while the vehicle was parked, turned on, and unoccupied, there was black smoke coming from the interior of the vehicle. The contact stated the footwell control module located on the driver's side had caught on fire. The vehicle was extinguished by the Fire Department. The vehicle was destroyed as it was consumed by the fire. A fire report was filed, and a fire report number was provided; however, the cause for the failure was not yet determined. A police report was not filed due to the incident occurring on private property. No injuries were sustained. The dealer was not contacted. The vehicle was not diagnosed or repaired. The vehicle was not towed and remained at the incident location. The manufacturer was made aware of the failure and a case was opened. The failure mileage was approximately 95,000. Parts…”

“THE CAR ENGINE STOPPED DEAD IN THE MIDDLE OF A STATE HIGHWAY WHILE GOING AT CRUISING SPEED OF 35MPH ON THE RIGHT MOST LATE, AND WITH ENGINE DEAD POWER STEERING BECAME UNRESPONSIVE AND BECAME IMPOSSIBLE TO STEER THE CAR TO THE SIDE. THE CAR WAS LITERALLY DEAD IN THE MIDDLE OF THE HIGHWAY, WE HAD KIDS ON BOARD AND FOR A SMALL CAR, WE WERE REALLY THAT LUCKY PASSING CARS WERE ABLE TO SPOT US AND AVOID HITTING US. WHEN WE TOOK TOWED IT TO THE SHOP, THE ISSUE WAS THAT THE TIMING CHAIN HAD SNAPPED AND ALSO CRACKED THE ENGINE TOP COVER ON THE LEFT SIDE. ON SEARCHING THE INTERNET IT LOOKS LIKE THIS IS THE "TIMING CHAIN, TENSIONER ISSUES" THAT BMW/MINI IS ALREADY AWARE OF HOWEVER THEY HAVE NOT YET DONE A RECALL. THERE WAS ALMOST NO WAY OF TELLING THERE WAS THIS PROBLEM BREWING WITH THE VEHICLE. ALTHOUGH NOW IN RETROSPECT THERE WERE A FEW TELL-TALE SIGNS, WHEN IT WAS COLD, WE HAD HEARD A RATTLE SOUND, WHICH WENT AWAY IMMEDIATELY. ALSO THE SAME DAY THE CAR ENGINE STOPPED WHEN STANDING AT A SIGNAL, BUT STARTED UP AGAIN. NOW WE REALIZE THAT THESE SIGNS WERE RELATED TO THE PROBLEM THAT OTHER USERS HAD COMPLAINED TOO BEFORE THE TIMING CHAIN BROKE.”

“THE REAR SPLIT DOORS WON'T OPEN WHEN UNLOCKING USING THE KEY FOB. THERE IS NO MANUAL LATCH TO OPEN REAR DOORS FROM THE INSIDE OF THE VEHICLE. THIS IS MY WIFE'S ONLY VEHICLE AND MY CONCERNS ARE AS FOLLOW. 1- WE CAN'T ACCESS THE SPARE TIRE AND EMERGENCY TOOLS SINCE THE DOORS DOESN'T OPEN. AND MY MAIN CONCERN IS 2- WHAT WILL HAPPEN IF THERE IS AN ACCIDENT/FIRE IN FRONT OF THE VEHICLE AND THE ONLY EMERGENCY EXIT IS THROUGH THE REAR OF THE VEHICLE UTILIZING THE REAR DOORS? DIFFERENT SCENARIO WHAT IF THE VEHICLE FALLS IN WATER AND THE ONLY WAY OUT IS TO OPEN THE REAR DOORS BUT THERE IS NO MANUAL LATCH TO EGRESS? I BELIEVE THAT MINI COOPER FAILED OR DIDN'T THINK ABOUT THIS MATTER. I CAN'T INCLUDE PICTURES BECAUSE I'LL BE SHOWING A SHUT DOOR.”

“CAR STARTED MAKING RATTLING NOISE ON START UP, DROVE IT TO MINI, THEY SAY MY TIMING CHAIN IS STRETCHED AND HOUSING BROKEN, AROUND $2500, TO REPAIR. READING ONLINE THIS IS A COMMON PROBLEM, EVEN THE BASIS OF A LAWSUIT AND I FEEL IT SHOULD BE LOOKED INTO. *TR”