2006 MINI Cooper electrical system problems

“BMW issued a Recall 15V-205 Safety Recall, to cover the Airbag sensor in the passenger seat of my vehicle, a 2006 Mini Cooper S. The failure error was in the airbag sensor in the passenger seat, and the system warned of potential hazard with the passenger airbag. My car had a recall fix in 2018 for this fault. Now some 4 years later the same fault has arisen in the same sensor and system. I returned to BMW Mini who carried out the previous recall to have this fixed again. They said that while their repairs and parts generally carry an 8-year warranty, they do not warrant Recall repairs. They wanted over $2,000 to fix this issue. As this is a repeat of the original fault, and the car has under 100,000 miles I believe it should be covered, as their repair and or part has again failed. The date below is when I took it for the recall and was refused the warrenty repair.”

“TL* THE CONTACT OWNS A 2006 MINI COOPER. AFTER THE CONTACT PARKED THE VEHICLE, SHE WAS ALERTED TO THE ODOR OF SMOKE DURING THE NIGHT. THE CONTACT APPROACHED THE VEHICLE, QUICKLY DISCONNECTED THE BATTERY, AND ROLLED THE VEHICLE HALFWAY DOWN THE DRIVEWAY OUT OF THE GARAGE. THERE WAS A TREMENDOUS AMOUNT OF HEAT FROM THE ENGINE, BUT THE VEHICLE COOLED DOWN. THE FIRE DEPARTMENT WAS NOT CONTACTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO STATED THAT THERE WAS AN ELECTRICAL FIRE FROM THE STEERING WHEEL PUMP AND MASSIVE REPAIRS WERE NEEDED, WHICH WOULD TOTAL APPROXIMATELY $3,500. THE MANUFACTURER WAS CALLED AND STATED THERE WAS NO RECALL ON THE VEHICLE. THE DEALER WAS NOT CONTACTED. THE INSURANCE COMPANY WAS CONTACTED. THE MANUFACTURER OFFERED TO COVER THE $500 DEDUCTIBLE FOR THE MECHANIC TO PERFORM THE REPAIRS THAT THE CONTACT WOULD HAVE TO PAY FOR IF THEY DECIDE NOT TO COVER THE CLAIM. THE FAILURE MILEAGE WAS 105,000.”

“TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 70 MPH, THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE VEHICLE WAS TOWED TO NICK ALEXANDER MINI (6201 ALAMEDA ST, LOS ANGELES, CA 90001) WHERE IT WAS DIAGNOSED THAT THE POWER STEERING PUMP, ALTERNATOR, AND RADIATOR COOLING FAN FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 80,054.”

“TL* THE CONTACT OWNS A 2006 MINI COOPER. THE CONTACT STATED THAT WHILE DRIVING AT APPROXIMATELY 60 MPH, THERE WAS A LOSS OF POWER STEERING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE THE POWER STEERING PUMP WAS REPLACED HOWEVER THE FAILURE RECURRED THE NEXT DAY. THE VEHICLE WAS TAKEN BACK TO THE MECHANIC AND UNKNOWN REPAIRS WERE PERFORMED. IN ADDITION, THE AIR BAG WARNING INDICATOR ILLUMINATED CONTINUOUSLY. ON A SEPARATE OCCASION, THE ALTERNATOR FAILED AND WAS NOT REPLACED. THE CONTACT MENTIONED THAT THE ENGINE COOLING FAN ALSO FAILED TO FUNCTION, WHICH CAUSED THE RADIATOR TO BE REPLACED TWICE. THE ENGINE WAS REPLACED AT A DIFFERENT TIME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 118,000.”

“TL* THE CONTACT OWNS A 2006 MINI COOPER S. THE CONTACT STATED THAT WHILE IN PARK, THE VEHICLE FAILED TO START. IN ADDITION, THE CONTACT STATED THAT WHILE REVERSING AT A LOW SPEED, THE STEERING WHEEL WAS DIFFICULT TO TURN. THE CONTACT HAD TO APPLY FORCE TO THE STEERING WHEEL IN ORDER TO STEER THE VEHICLE. ONCE IN PARK, THE VEHICLE FAILED TO TURN OFF WITH THE KEY IN THE OFF POSITION. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE POWER STEERING MOTOR HAD FAILED AND MELTED. THE POWER STEERING MOTOR, WIRES, BATTERY, PUMP, FAN, PRESSURE HOSE AND ALTERNATOR WERE REPLACED. AFTER REPAIRS, THE MECHANIC WAS UNABLE TO DIAGNOSE THE VEHICLE USING THE DIAGNOSTIC TOOL. THE VEHICLE WAS THEN TAKEN TO A DEALER WHO STATED THAT THE WIRING HARNESS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT WAS AWARE OF NHTSA CAMPAIGN NUMBER: 15V660000 (STEERING) BUT THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 98,000.”

“TL* THE CONTACT OWNS A 2006 MINI COOPER. WHILE DRIVING 60 MPH, THE VEHICLE LOST POWER. ALSO, WHEN MAKING A LEFT OR RIGHT TURN, THE ENGINE LIGHT ILLUMINATED FOR A SECOND AND DIMMED. THE FAILURE RECURRED EACH TIME THE VEHICLE WAS DRIVEN. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED, BUT THE CAUSE OF THE FAILURE COULD NOT BE LOCATED. THE FAILURE RECURRED. IN ADDITION, WHILE DRIVING 54 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT COASTED THE VEHICLE OVER TO THE SIDE OF THE ROAD AND IT BEGAN TO SMOKE AND LEAK OIL. THE DEALER DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 52,000.”