2014 Ram 1500 fuel/propulsion system problems

“Ram has a recall for this vehicle for the fuel tank strap attachment point on the frame. It is their x75 recall. The part on my truck is completely rotted out exactly why the recall was made. My truck is 8 months outside of the recall period so Ram will not replace the part. The frame has obviously been rotting for a long time and who knows how long the fuel tank has only been supported with one strap. This is a huge safety concern and one that Ram is refusing to repair because it is outside of the time line. I can provide photos of the rotted out area as well as strap that is rotting as well. A known issue like this should not have a time line and should be replaced at no cost. Original in service date for the vehicle was February 18, 2014”

“The front fuel tank strap mounting bracket broke. There is a recall (U-04/NHTSA 18V-160) for model years 2009-2012 for this issue. It also was added to models thru 2018 as TSB/Ext. Warranty #14-002-18 Rev. A., which expired on my vehicle in March 2026. This means that the expense will be out of my pocket. What I don't understand is, it is a known safety issue on 2009-2018 Ram 1500 trucks, but only a recall for model years 2009-12. And since the recall doesn't presently cover my model year (2014), there was no notification of this issue sent to me. I believe that since it is a known issue included in a recall/TSB of model years through 2018, the recall should be extended to cover all model years. This failure could put myself and others at risk because there is only one bracket holding my fuel tank on, which could cause loss of control of vehicle or a fire to the vehicle if the remaining bracket breaks. This issue was discovered by a private auto repair shop, in which there were no warnings signals from the vehicle.”

“Check Engine light came on with a code P0463. This indicates that the fuel level sensor is bad. This is a VERY common issue on these trucks. It causes the vehicle to no longer go into "ECO" mode which is wasting fuel. This happens every time I fill the gas tank and does not go away until the tank reaches 3/4 tank. The part is garbage and is known to fail.”

“This complaint concerns failure of the remedy for Safety Recall Z46 / NHTSA Campaign 22V406 involving the high pressure fuel pump (HPFP) on a 3.0L diesel pickup. The HPFP had previously been replaced under the recall by an authorized dealer. About 19 months later, while the vehicle was at a dealership for service, the replacement HPFP failed again during dealer testing. The dealer documented metal contamination throughout the fuel system caused by the HPFP failure. The dealer then replaced the contaminated fuel system components. After those repairs and during post-repair test driving, the vehicle developed new bottom-end engine noise. The dealer later documented connecting rod bearing damage / rod knock and recommended complete engine replacement. The vehicle had been brought in with no bottom-end engine noise, and the dealer’s intake inspection documented oil condition as OK. An independent oil analysis later showed the engine oil was normal and did not indicate long-term lubrication failure. This suggests the engine damage occurred acutely after the HPFP failure and resulting contamination event, not from routine wear. This condition creates a serious safety…”

“Fuel sensor failure. Began around 60,000 miles. Unless tank is full tank will display as empty. This also causes the check engine light to be on. Causes me to never know how much fuel is in the tank. I have nearly run out of fuel several times. This is a known issues across Dodge RAM forums for this era of RAM. It is not safe to operate at speed and run out of fuel unexpectedly.”

“While changing oil, noticed the front fuel tank strap was disconnected from the frame. Upon closer inspection, the outboard front fuel tank strap mounting location on the frame rusted through, allowing the T portion if the strap to fall lose. There is a similar recall for 08-12 Ram 1500's, but clearly this issue persists for more than just those model years”