2002 Saab 9-5 electrical system problems

“IGNITION SWITCH SHUT OFF WHILE ON A BUSY HIGHWAY TWICE! ONCE IN 2006 AND ONCE LATER ANOTHER YEAR PLUS ONCE IN A DRIVEWAY (CAR PURCHASED USED IN THE FALL OF 2005). THE SAAB SWITCH IS LOCATED IN THE CENTER CONSOLE AND IF IT IS HIT IT SWITCHES OFF AND SHUTS DOWN THE CAR, SAME AS RECALLED SWITCHES IN OTHER GM CARS. VERY DANGEROUS ON THE HIGHWAY, BUT I WAS LUCKY AND ABLE TO STEER TO THE SIDE WITHOUT A CRASH. THERE SHOULD HAVE BEEN A LOCK MECHANISM TO PREVENT IT FROM HAPPENING. IT NEVER OCCURRED TO ME TO REPORT IT THOUGH IT IS DEFINITELY A SAFETY HAZARD IN A WHAT WAS AT THE TIME A GM OWNED PRODUCT. I STILL OWN THE CAR AND DRIVE IT DAILY ON THE SAME HIGHWAY, HOWEVER AM VERY MUCH AWARE OF THE ISSUE. I WASN'T AWARE OF WHAT CAUSED THE SHUT DOWN UNTIL IT HAPPENED THE SECOND TIME A FEW MONTHS AFTER THE FIRST TIME. YOU SHOULD INCLUDE SAAB IN THE RECALL OF GM PRODUCTS. *TR”

“TL* THE CONTACT OWNS A 2002 SAAB 95. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE STALLED ON A MAJOR HIGHWAY. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE FAILURE WAS DIAGNOSED BY AN AUTHORIZED DEALER WHO STATED TO REPAIR THE DIRECT IGNITION CASSETTE. THE FAILURE RECURRED MULTIPLE TIMES AFTER IT WAS REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 48000. *TR”

“TL* THE CONTACT OWNS A 2002 SAAB 9-5. WHILE DRIVING AT SPEEDS OF 40 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE LOST POWER STEERING AND BRAKING ABILITY. THE CONTACT WAS ABLE TO MOVE THE VEHICLE OFF THE ROADWAY AND RESTART THE VEHICLE. THE VEHICLE RESUMED NORMAL OPERATION UPON RESTARTING. THE DEALER WAS CONTACTED AND ADVISED THAT THE ELECTRICAL IGNITION MODULE WOULD NEED TO BE REPLACED. IN ADDITION, THERE WAS A RECALL FOR THE FAILURE YET HIS VIN WAS NOT INCLUDED IN THE CAMPAIGN (NHTSA CAMPAIGN ID NUMBER 06V410000- ELECTRICAL SYSTEM: IGNITION: MODULE. THE MANUFACTURER CONFIRMED THE DEALER'S ADVICE AND WOULD NOT PROVIDE ANY ASSISTANCE. THE FAILURE AND CURRENT MILEAGE WAS 103,000.”

“WE HAVE A COMPLAINT REGARDING RECALL 05V399000 FOR OUR 2002 SAAB 9-5 AERO. OUR IDM SERIAL NUMBER FALLS WITHIN THOSE REQUIRED TO BE REPLACED BY THE RECALL. HOWEVER, SAAB WILL NOT REPLACE IT BECAUSE OUR VIN # DOES NOT FALL WITHIN THEIR RECALL. OUR IDM NEEDS TO BE REPLACED. THIS DOES NOT MAKE SENSE. OUR SAAB WAS DELIVERED IN GERMANY (IT IS US SPEC) TO A SERVICEMEMBER STATIONED THERE. WE BOUGHT IT USED WHILE STATIONED OVER THERE. NO RECALL NOTICES WERE SENT TO US OVER THERE. WE JUST STARTED GETTING RECALL NOTICES ONCE WE SHIPPED THE CAR TO THE STATES. WE HAD TO PROVIDE OUR CERTIFICATE OF ORIGIN TO SAAB. SAAB TOLD US THEY HAD NO IDEA OUR CAR EXISTED UNTIL WE GAVE THEM THE CERTIFICATE OF ORIGIN (WHICH SOUNDS FISHY). THIS RECALL WAS ISSUED BEFORE WE MOVED BACK TO THE STATES. OUR DEALERS SERVICE DEPARTMENT SAYS OUR IDM SERIAL NUMBER AND THE PROBLEM WITH IT FALL WITHIN THE RECALL. BUT SAAB WILL NOT REIMBURSE THEM FOR REPLACING IT. *TR”

“2002 SAAB 9-5 HAS HAD FAILURE OF HEADLIGHT BULBS AT A RATE OF ONE OR TWO PER YEAR FROM THE VERY FIRST YEAR I HAVE OWNED THIS CAR. NO OTHER BULB HAS BURNED OUT IN THE PAST 8 YR. A LOCAL GARAGE MECHANIC TOLD ME IT WAS RELATED TO A FAULTY FRONT ELECTRICAL HARNESS IN THE SAAB BUT THE DEALER SAID THIS WAS NOT A RECALL, EVEN THOUGH IT HAS BEEN A PROBLEM FROM THE FIRST YEAR OF OWNERSHIP. NOW I HAVE 2 HEADLIGHT BULBS BURNING OUT WITHIN ONE DAY OF EACH OTHER -- ONE HIGH BEAM, ONE REGULAR. IS THERE A RECALL OF ELECTRICAL HARNESS ON SAABS TO CORRECT FREQUENT HEADLIGHT BULB BURNOUT? SO FAR I HAVE JUST BEEN REPLACING THE BULBS AT $50/BULB AT THE RATE OF ONE OR TWO PER YEAR. *TR”

“LOSS OF REVERSING LIGHTS, TRUNK OPENING WARNING LIGHT AND CRUISE CONTROL FUNCTION WITH NO INTERNAL WARNING INDICATIONS. UPON INVESTIGATION, THE CAUSE WAS THE FAILURE OF TRUNK WIRING HARNESS AT 70K MILES - 2 WIRES WERE COMPLETELY SEVERED, ALL OTHERS (6) HAD LOST INSULATION. FAILURE IS AT THE FOLDING POINT JUST PRIOR TO ENTRY INTO THE TRUNK LID. CAUSE APPEARS TO BE EXCESSIVE TIGHTNESS OF THE INTERIOR WIRES. THE RUBBER BOOT WAS ENTIRELY INTACT, SEALED TO CONNECTORS IN THE BODY AND TRUNK LID AND THERE WAS NO VISIBLE INDICATION OF THE INTERNAL FAILURE. WIRES ARE SEPARATE INSIDE THE BOOT UP UNTIL THE TRUNK LID ENTRY WHERE THEY ARE WRAPPED WITH ELECTRICAL TAPE. THIS WAS DISCOVERED ONLY DURING SERVICE, NOT REPORTED BY SELF-CHECK DISPLAY WHICH ALWAYS REPORTS LIGHT BULB OUTAGES IN TEXT MESSAGES ON THE 2 LINE SAAB INFORMATION DISPLAY (SECONDARY FAILURE). PRIOR TO DISCOVERY A NUMBER OF CARS HAD ALMOST REAR ENDED THE CAR WHEN BACKING UP (REVERSING LIGHT FAILURE WAS NOT REPORTED OR KNOWN). CORRECTED TEMPORARILY BY SPLICING IN WIRES AND HEAT WRAPPING, WAITING FOR APPOINTMENT WITH THE SAAB DEALER TO REPLACE THE HARNESS. *TR”