Problems · NHTSA complaints
2005 Saab 9-5 problems
Owners filed 11 complaints about the 2005 Saab 9-5 with NHTSA between Nov 2009 and Dec 2012. The most-cited component is air bags (2).
Complaints
11
Filed with NHTSA
Crashes
2
Reported by owners
Fires
0
Reported by owners
Injuries
1
People reported injured
Deaths
0
Reported to NHTSA
Complaints by component
One complaint can cite several components
- Air bags2
- Electrical system2
- Exterior lighting2
- Equipment2
- Suspension2
- Fuel/propulsion system1
- Engine1
- Engine and engine cooling1
- Power train1
- Structure1
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.
Data from NHTSA Complaints API · synced Nov 9, 2026NHTSA vehicle page
When complaints were filed
Does it get worse with age? Complaints per calendar year filed
1
2
3
5
View as table
| Model year | Complaints filed per calendar year |
|---|---|
| 2009 | 1 |
| 2010 | 2 |
| 2011 | 3 |
| 2012 | 5 |
Mileage at failure isn’t a structured field in NHTSA complaint data, so we don’t chart it. Some owners mention it in their reports below.
Top problems in owners’ words
Verbatim from NHTSA complaints, newest first
Air bags
2 reports2 crashes
“I WAS INVOLVED WITH IN AN ACCIDENT ON FRIDAY DECEMBER 14TH, 2012. I WAS RETURNING TO WORK ON MY LUNCH BREAK AND A LADY RAN A RED LIGHT, PULLING OUT INFRONT OF ME, AND I ENDED UP T-BONING HER GOING ROUGHLY 45MPH. I WAS EXTREMELY DISAPPOINTED THAT NO AIR BAGS WERE DEPLOYED IN SUCH A SEVERE HEAD ON COLLISION. THE CAR HAS BEEN SEEN BY THE INSURANCE COMPANY AND THEY DECIDED TO TOTAL THE VEHICLE. IN SUCH A VIOLENT ACCIDENT I WOULD EXPECT THE AIR BAGS TO BE DEPLOYED, ESPECIALLY WHEN THE ACCIDENT WAS A FRONT ON COLLISION THAT TOTALED MY SAAB. I WAS TAKEN TO THE ER BECAUSE I HIT MY HEAD ON THE A FRAME AND HAD MAJOR BACK AND NECK PAIN. THIS PROBLEM ABOUT THE AIR BAGS NOT GOING OFF NEEDS TO BE KNOWN, AND I AM VERY DISAPPOINTED THAT THIS VEHICLE DID NOT MEET THE BASIC STANDARDS FOR SAFETY IN A HEAD ON COLLISION. *TR”
Electrical system
2 reports
“RUNNING LIGHTS WILL NOT TURN OFF, EVEN AFTER THE CAR IS STOPPED AND THE KEY IS OUT OF THE IGNITION, CAUSING THE BATTERY TO RUN DOWN. *JS”
Exterior lighting
2 reports
“BECAUSE OF IMPROPER DESIGN, REAR WIRE HARNESS FOR REVERSE LIGHTS ARE BEING SEVERED CAUSING THE REVERSING LIGHTS NOT TO WORK. THIS SAME DESIGN FLAW CAN BE ATTRIBUTED TO THE FAILURE OF BRAKE LIGHTS AND ELECTRONIC TRUNK RELEASE/LOCK. *TR”
Equipment
2 reports
“THE IGNITION CASSETTE NEEDED TO BE REPLACED. *TR”
Suspension
2 reports
“NOTICED ABNORMAL / EARLY REAR TIRE WEAR. NOTICED ABNORMAL (OUT OF MANUFACTURERS SPEC.) REAR CAMBER. NOTICED REAR SUSPENSION BOTTOM OUT WITH MODERATE LOADS (APPROX 1/2 OF MAX LOAD). OEM REAR TIRES CUPPED AND REQUIRED REPLACEMENT PREMATURELY DUE TO ABNORMAL REAR CAMBER. NEW TIRES INSTALLED. REAR AFTERMARKET CAMBER SHIMS INSTALLED. *TR”
Fuel/propulsion system
1 report
“TL* THE CONTACT OWNS A 2005 9-5 SAAB. THE CONTACT STATED THAT WHILE TRAVELING 70 MPH, THE CHECK ENGINE WARNING LIGHT ILLUMINATED REPEATEDLY AS THE VEHICLE BEGAN TO SPUTTER AND JERK. THE CONTACT THEN MERGED TO THE SIDE OF THE ROAD WHERE THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE DRIVEN TO THE CONTACT'S RESIDENCE AND WAS LATER TAKEN TO A PRIVATE MECHANIC WHERE IT WAS CONFIRMED THAT THE FUEL LINE FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED. THE FAILURE AND CURRENT MILEAGES WERE 122,000. THE VIN WAS NOT AVAILABLE.”
Data from NHTSA Complaints API (owner reports, unverified) · synced Nov 9, 2026
Complaints are unverified owner reports to NHTSA and are not normalized for sales volume. One complaint can cite several components.