2000 Saturn LS steering problems

“TL* THE CONTACT OWNS A 2000 SATURN LS. WHILE DRIVING APPROXIMATELY 25 MPH, THE CONTACT NOTICED AN ABNORMAL NOISE FROM BOTH THE FRONT PASSENGER AND DRIVER SIDES OF THE VEHICLE. IN ADDITION, THE CONTACT STATED THAT THE STEERING WHEEL WAS DIFFICULT TO TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THERE WAS CORROSION AROUND ALL OF THE WHEEL WELLS AND THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 150,000.”

“DRIVING DOWN THE ROAD THE VEHICLE STARTED MAKING NOISE AND STEERING WAS UNCONTROLLABLE. I TRAILERED THE VEHICLE BACK HOME. CLOSER INSPECTION REVEALED THE FRONT SUBFRAME/ENGINE CRADLE WAS COMPLETELY RUSTED THROUGH IN MULTIPLE SPOTS, VERY DANGEROUS!!! I CONTACTED THE DEALER TO GET A NEW SUBFRAME AND I WAS ADVISED THE SUBFRAME IS NO LONGER AVAILABLE AND TO TRY FINDING ONE IN A SALVAGE YARD. I CONTACTED A SALVAGE YARD AND THEY SAID THEY HAD A FEW AND IT WOULD BE NO PROBLEM TO PULL ONE. I GOT THE CALL TODAY SAYING THEY WERE SORRY BUT ALL OF THE FRONT SUBFRAMES ON THE SATURN L SERIES THEY HAVE ARE RUSTED THROUGH AND ARE NOT USABLE. I CONTACTED OTHER YARDS WITH THE SAME RESPONSE. I ENDED UP HAVING TO FIND A SALVAGE YARD DOWN SOUTH THAT HAD A USABLE SUBFRAME. I WENT ONLINE TO FIND NUMEROUS FORUM POSTS DISCUSSING THIS TOPIC AND I'M FINDING IT IS VERY COMMON ON THIS VEHICLE. WHY WAS THERE NEVER A RECALL FOR THIS WITH SUCH A WIDESPREAD SAFETY HAZARD? FROM WHAT I CAN TELL IT HAPPENS ON ALL MODEL YEARS OF THE L SERIES. THE IRONY IS THE REST OF THE CAR IS VERY CLEAN, NO RUST ON THE REST OF THE UNDERCARRIAGE. THERE IS NO CLEAR EXPLANATION WHY THE SUBFRAME WOULD HAVE CORROSION…”

“I HAD JUST GONE TO THE GAS STATION TO FILL UP MY 2000 SATURN LW2 WHEN I WAS ABOUT TWO BLOCKS FROM THE GAS STATION. I WAS RIGHT AROUND THE CORNER FROM MY HOUSE, AND HAD JUST TURNED RIGHT ONTO A STREET WITH A HILL. SUDDENLY, MY CAR STARTED SPUTTERING SO I IMMEDIATELY TRIED TO PULL OVER. I WASN'T COMPLETELY OUT OF THE STREET WHEN I SUDDENLY LOST ALL POWER BRAKES AND POWER STEERING GOING DOWN THE HILL AT 25 MILES PER HOUR. I COULDN'T STOP THE CAR SO I PUT IT IN PARK, WHICH STOPPED IT INSTANTLY, CAUSING MY NECK TO JERK, WHICH HAS BEEN SORE FROM WHIPLASH FOR THE PAST FOUR DAYS SO FAR. I HAD THE CAR TOWED TO THE MECHANIC WHO FOUND BITS OF MY TIMING BELT ALL THROUGH THE MOTOR, WHICH BLEW THE ENTIRE ENGINE. AFTER HEARING THAT IT WOULD BE OVER $3,000 FOR A USED ENGINE INSTALLED, WE'VE BEEN TRYING TO DETERMINE OUR NEXT MOVE, FINANCIALLY. *TR”

“THIS HAPPENED VERY SUDDENLY. I APPLIED THE BRAKE TO ENTER THE RAMP TO THE HIGHWAY AND THE CAR PULLED TO THE LEFT AND MADE A NOISE. I THOUGHT IT MAY BE A BEARING OR BRAKE PROBLEM BUT I HAD NOT HAD ANY ISSUES BEFORE THAT SO I WENT ON SINCE IT SEAMED TO BE DRIVING OK. WHILE I WAS ON THE INTERSTATE I WENT TO GO INTO THE LEFT LANE AND REALIZED THERE WAS A SERIOUS PROBLEM WITH THE STEERING. I SLOWED DOWN AND GOT OFF THE HIGHWAY TO THE SHOP. I WAS TOLD THERE THE K FRAME HAD LESS THAN 1/2" BEFORE BREAKING COMPLETELY AND COULD HAVE BEEN A SERIOUS ACCIDENT SINCE IT HAS TO DO WITH STEERING. I HAVE REGULAR MAINT ON THE CAR AND THERE WAS NO INDICATION THAT THIS MIGHT HAPPEN. THE UNDERSIDE IS IN VERY GOOD SHAPE. I HAD THE FRAME REPLACED. I FEEL IT WAS A DEFECT IN THE FRAME. I'M SURE IM NOT THE ONLY ONE THIS HAS HAPPENED TOO. *KB”

“TL* THE CONTACT OWNS A 2000 SATURN LS SERIES. THE CONTACT STATED THAT WHEN TURNING THE KEY TO TURN ON THE VEHICLE, THE STEERING WHEEL WOULD SEIZE. THE DEALER WAS NOTIFIED OF THE FAILURE AND THE CONTACT MADE AN APPOINTMENT FOR THE VEHICLE TO BE DIAGNOSED. THE MANUFACTURER WAS NOT CONTACTED AND THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 44,000 AND THE CURRENT MILEAGE WAS 44,200.”

“VEHICLE PULLED WHEN BRAKING. SYMPTOMS STARTED ON A MONDAY AS A LIGHT PULL. MORE NOTICEABLE ABOVE 50 MPH, AND NOT NOTICEABLE BELOW 35. BY THURSDAY MORNING, PULL WAS SEVERE ABOVE 50MPH. STAYED TILL AFTER 6:00 AT NIGHT TO AVOID TRAFFIC. RIDE HOME WAS "ENTERTAINING" AS STEERING WHEEL DID NOT ALWAYS GO BACK TO "CENTER" WHEN GOING STRAIGHT. I THOUGHT I NEEDED A STEERING RACK UNTIL I INSPECTED THE VEHICLE ON SATURDAY. MY INSPECTION SHOWED THAT FRONT SUBFRAME (A.K.A. ENGINE CRADLE) FAILED WHERE THE "PASSENGER SIDE LOWER CONTROL ARM REAR BUSHING WAS ATTACHED". A SIZABLE PIECE OF FRAME RIPPED OUT, WITH BUSHING STILL ATTACHED TO LOWER CONTROL ARM. RUSTED PERFORATIONS IN SUBFRAME VISIBLE APPROXIMATELY 6" BEHIND WHERE FRAME FAILED. TWO SETS OF RIMS (SUMMER AND WINTER) WITH NO "DINGS" TESTIFIES THAT VEHICLE NEVER EVEN HIT A CURB IN 170,000 MILES. 4 CYLINDER, SO NO EXHAUST NEARBY TO "WEAKEN STEEL". BAD CHOICE OF CORROSION PROTECTION IN A CRITICAL PART OF THE FRAME, AND/OR UNDERSIZING OF STEEL THICKNESS TO ACCOMMODATE FOR CORROSION IS MY ESTIMATE OF "FAILURE MODE". CONTACTED DEALER AND NO REPLACEMENT PARTS AVAILABLE. WELL MAINTAINED VEHICLE, VERY DISAPPOINTED IT FAILED THIS…”