2006 Toyota Corolla engine and engine cooling problems

“The contact owns a 2006 Toyota Corolla Matrix. The contact stated while driving 45 MPH, the check engine warning light and the battery warning light illuminated, and the vehicle lost motive power. The contact was able to restart the vehicle and pull over on the side of the road safely where the vehicle shut off again and failed to restart. The vehicle was towed to an independent mechanic who stated that the vehicle had experienced a similar failure as in NHTSA Campaign Number: 10V384000 (Engine and Engine Cooling) and advised to take the vehicle to the dealer. The dealer was not contacted. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was 200,025.”

“CHECK ENGINE LIGHT CAME ON RANDOMLY 5 TIMES OVER THE PAST 2 MONTHS. FILED COMPLAINT WITH TOYOTA. ECM SEEMS TO BE ACTING UP, THEY THINK IT'S AN ISSUE WITH A MANIFOLD GASKET. TAKING VEHICLE TO DEALER THIS WEEK TO HAVE THEM DIAGNOSE THE ISSUE. *TR”

“TOYOTA HAS ISSUED A TECHNICAL SERVICE BULLETIN INDICATING THAT THE A/C CONDENSER IS NOT PROPERLY PROTECTED, CAUSING PREMATURE FAILURE OF THE CONDENSER UNIT. THE NUMBER FOR THIS REPORT IS AC002-06. MY A/C CONDENSER HAS FAILED DUE TO THE FAULTS IN THIS CONDENSER UNIT. I SPOKE WITH TOYOTA AT 1-800-331-4331, AND THEY ACKNOWLEDGE THAT THE PART IS FAULTY, BUT REFUSE TO COVER THE REPLACEMENT OF THIS FAULTY UNIT AS PART OF A RECALL. I'M CONCERNED THAT, IF TOYOTA ACKNOWLEDGES THAT THIS PART IS FAULTY, THEY REFUSE TO REALL AND REPLACE THIS PART. *TR”

“ON MAY 19, 2013 MY HUSBAND AND CHILDREN WERE AT A REST STOP...OUR 2006 TOYOTA COROLLA WAS PARKED ENGINE ON WITH THE AIR CONDITION ON AS WELL WHEN THEY HEARD A LOUD EXPLOSION FROM THE BACK OF THE CAR THE REAR WINDSHIELD HAD SHATTERED INTO A MILLION PIECES. IT IS STILL BEING HELD UP BY THE TINT. WE TOOK THE CAR IN TO ATKINS KROLL TOYOTA DEALERSHIP AND THEY JUST KEPT TELLING US THERE WAS NOTHING THEY COULD DO BECAUSE IT WASN'T A RECALL. THIS IS A HUGE SAFETY ISSUE... MY CHILDREN COULD HAVE HAD SHARDS OF GLASS ALL OVER THEIR FACES IF IT WASN'T FOR THE TINT OR HAD THEY BEEN DRIVING ON THE ROAD COULD HAVE CAUSED AN ACCIDENT. THERE SHOULD DEFINITELY BE A RECALL ON THIS. WHILE STILL AT THE DEALERSHIP WE WERE REFERRED TO THE BODY SHOP TO GET IT INVESTIGATE IT AND THE BODY MAN SAID IT COULD HAVE BEEN CAUSED BY THE METAL CLIPPINGS THAT HOLD THE WINDSHIELD TOGETHER BUT STILL TO NO AVAIL. *TR”

“HEAT SHIELD HANGER ASSEMBLY FAILED AND NOW HEAT SHIELD VIBRATES AGAINST EXHAUST PIPE MAKING TERRIBLE NOISE. THIS IS A VERY COMMON PROBLEM AS RESEARCHED ON THE NET. TOYOTA NEEDS TO FIX THIS FREE. *TR”

“AC CONDENSER STATED LEAKING ON 12/18/2011. STEAM WAS COMING OUT OF FRONT OF THE CAR AS IT WAS PARKED AT A STORE. I NOTICED THIS WHEN I WAS EXITING THE STORE. TWO GARAGES CONFIRMED THAT IT WAS THE CONDENSER. I WENT TO DO RESEARCH ON THE CONDENSER ONLINE AND THE COMPLAINTS ABOUT DEFECTIVE CONDENSERS ON THE 2005 AND 2006 COROLLA APPEARED ON THE WEB. PROBLEM WAS CORRECTED ON THE 2007 AND AFTER COROLLA. CONDENSER HAS TO PROTECTION. COULD HAVE THE CONDENSER REPLACED TODAY AND BECAUSE OF NO PROTECTION, THE PROBLEM COULD HAPPEN AGAIN THE NEXT DAY. VERY POOR DESIGN...THIS LEAVES THE OWNERS OF 2005 AND 2006 COROLLAS OUT IN THE COLD! WHY NO RECALL??? ONE OF THE GARAGES THAT I WENT TO WAY A TOYOTA DEALERSHIP...THEY WANT $735 (ESTIMATE) TO CORRECT THE PROBLEM. IT WAS POOR DESIGN! I SHOULD NOT HAVE TO PAY FOR HEIR MISTAKE! *TR”